Академический Документы
Профессиональный Документы
Культура Документы
OBD Locations
cover. Loosen the air filter assembly, this allows easier access to the ECU. Bosch 0281ECU Location : FordModelECU
LocationOBD LocationECU ID CodeKAInside car on A post offsideUnder steering wheel above pedal
assemblyEEC5Fiesta/TurboUnder glove box nearside EEC4/5EscortInside car on A post offside or under under centre
console EEC4/5Escort RS TurboUnder bonnet behind heater fan box EEC4/5FocusInside car behind kick panel
offsideUnderneath steering wheel, above pedal assembly. Will need to remove cover to access OBD
Port.EEC5Sierra/SaphireBehind glove box EEC5MondeoInside car above accelerator pedalUnder steering wheel above
pedal assemblyEEC4/5Granada/ScorpioBehind glove box EEC4/5TransitInside van above glove boxUnder steering
wheel above pedal assembly.EEC4/5 or Lucas on DieselGalaxy <2000Behind instruments in facia EEC4/5 or 0281 on
DieselGalaxy >2000Under bonnet next to battery Bosch 0261 / 0281ProbeInside car under centre console EEC4/5 or
MazdaCougarInside car above accelerator pedalUnder steering wheel above pedal assemblyEEC5Transit
ConnectDELPHI must be done using BDM100 Kit, the ECU can be found on drivers side 'A Post'.EEC5 are covered by
SRS, the OBDII is on the drivers side of the transmission tunnel, by drivers left knee.EEC5 / DELPHIFocus 1.6 TDCi
110bhpBehind nearside wheel arch. Bosch EDC16Focus ST 2.5The ECU is located on the air filter assembly on the front
of the engine. Bosch ME9Fiesta 1.6 TDCi 90bhp Above drivers feet behind OBD coverEDC16S-Max 2.5 T To the right of
the steering wheel, open panel, then at top another small panel covering the OBD2 port.Bosch ME9Mondeo/S-Max 2.0
TDCi 138bhp The OBDII sockets are in the dashboard below right of steering wheel behind two hinged covers.Siemens
SID2062007 Transit 2.4 TDCi Above drivers feet behind trim panelVisteon Focus/Fiesta/C-Max/Fusion The OBDII sockets
are in the dashboard below right of steeringSiemens SIM210ECU Location : HondaModelECU LocationOBD
LocationECU ID CodeGeneralUnder carpet nearside front footwell Honda PGM-FINSXInside car behind seat
offside Honda PGM-FICivic 1.7 CTDI 2002 onBehind glove box. Bosch 0281Accord 2.2 iCDTiThe ECU is located on the
passengers A post. Bosch EDC16Civic i-CDTi 2.2ECU on the passenger side on A-pillar behind glove box. You need to
remove the arm rest, slide out the way to remove the glove box. Bosch EDC16 CRVAbove the passengers feet behind
the lower panel, sits on a removable shelf. EDC16ECU Location : HyundaiModelECU LocationOBD LocationECU ID
CodeGeneralInside car on A post offside Bosch 0261S Coupe/TurboUnder carpet nearside front footwell Bosch
0261Tucson 2.0 CRTD 2007 onThe ECU on the Tucson is located above the pedal assembly in the driver's foot well,
behind a panel which is easily removed. Bosch EDC16ECU Location : IsuzuModelECU LocationOBD LocationECU ID
CodePiazzaInside car on A post offside Bosch 0261Trooper 3.0DUnder the bonnet on passengers side near
battery DelcoRodeo 3.0DUnderneath the steering wheel BoschECU Location : JaguarModelECU LocationOBD
LocationECU ID CodeGeneralInside car behind kick panel nearside Lucas S-Type / XJ Series The OBD Port is located
above the pedal assembly towards the centre.Siemens SID201ECU Location : KiaModelECU LocationOBD LocationECU
ID CodeGeneralUnder carpet nearside front footwell Bosch 0261ECU Location : LanciaModelECU LocationOBD
LocationECU ID CodeGeneralUnder centre console Webber MarelliECU Location : Land RoverModelECU LocationOBD
LocationECU ID CodeTD5 Discovery/TD6 Range RoverEngine Bay drivers side behind battery in plastic boxAbove
drivers left knee.Lucas MemsTD4 Passengers footwell on right hand sideBosch DDEDiscovery 3 2.7 V6 TDiRemove
battery, then unscrew front panel and lid behind battery. Tape first ECU out the way, the second ECU - Siemens SID201
is the one to be remove. Siemens SID201Range Rover/Sport TDV8 Above drivers feet - OBD2.Siemens
SID203Freelander 2.2 TD4 Above Drivers FeetBosch EDC16 2007 Defender 2.4 Di Above drivers feet behind trim
panel.VisteonECU Location : LotusModelECU LocationOBD LocationECU ID CodeCarltonBehind glove box Delco
MemcalElanInside car on A post offside Delco MemcalEliseIn engine compartment on firewall Lucas MEMSECU Location
: MGModelECU LocationOBD LocationECU ID CodeZR/ZS (All Models) Drivers footwell, above left knee. ZT (All
Models) Drivers footwell, above right knee. TF (All Models) Drivers footwell, unscrew cover above right knee. ECU Location
: MaseratiModelECU LocationOBD LocationECU ID CodeGeneralInside car under centre console Webber MarelliECU
Location : MazdaModelECU LocationOBD LocationECU ID CodeGeneralInside car under centre console HitachiECU
Location : MercedesModelECU LocationOBD LocationECU ID CodePetrolUnder bonnet offside of engine bay Bosch
0261DieselUnder bonnet nearside of engine bay Bosch 02811.7l/2.0l/2.2l/2.7l/3.2l CDI - early models 1999Under bonnet,
nearside of engine bay.Require MERC-OBD lead, under bonnet LHS of engine bay.Bosch
EDC15C51.7l/2.0l/2.2l/2.7l/3.2l CDI 2000-2002 All ModelsUnder bonnet, nearside of engine bay.Require OBD II lead,
above drivers knees behind trim panel.Bosch EDC15C5Vito CDI 108/110/112Above drivers pedals.Require MERC-OBD
lead OR standard OBD II lead, under passengers seat.Bosch EDC15C52.4l/2.8l/3.2l V6 Petrol, models 2000 on with
ECU ID Code as listed.Under bonnet, offside of engine bay.Require OBD II lead, port above drivers knees behind trim
panel.Bosch 2.7/2.84.3l/5.0l V8 Petrol, models 2000 on with ECU ID Code as listed.Under bonnet, offside of engine
bay.Require OBD II lead, port above drivers knees behind trim panel.Bosch 2.7/2.86.0l V12, models 2001 on with ECU
ID Code as listed.Under bonnet, offside of engine bay.Require OBD II lead, port above drivers knees behind trim
panel.Bosch 2.7.1Vito 109/111/115 CDIIn engine bay, large plastic box at rear, ECU inside. Bosch EDC16ML c.2005The
ECU is located behind the off-side wheel arch. Drop the wheel arch trim down, the ECU is located in a cradle which is
held back near the A post. The ECU is held into the cradle with one screw. E 320 CDI 224bhp / 280 CDIThe ECU is
located on the passenger side of the engine bay, in a black plastic box. Bosch EDC16B Class 200 CDIThe ECU is
located on the far right hand side of the engine bay on the bulkhead. Bosch EDC16A/B Class 180 CDIUnder the bonnet
on the bulkhead on the passengers side. Bosch EDC16ECU Location : MiniModelECU LocationOBD LocationECU ID
CodeOne & Cooper Above drivers footwellSiemensR56 Mini Cooper S 1.6 TurboThe ECU is located in the driver's side of
the engine bay under a plastic cover next to the battery. Bosch MED17R56 Mini Cooper 1.6 DieselThe ECU is located in
the driver's side of the engine bay under a plastic cover next to the battery. Bosch EDC16ECU Location :
MitsubishiModelECU LocationOBD LocationECU ID Code3000 GTOInside car under centre
console MitsubishiGallantInside car under centre console MitsubishiStarionInside car on A post nearside MitsubishiGrandis
DiDPassengers Footwell in metal plate Bosch EDC16ECU Location : NissanModelECU LocationOBD LocationECU ID
http://www.dnatuning.com Powered by Joomla! Generated: 23 May, 2011, 15:58
DNA Tuning - ECU and Performance Specialists
Code200/300Under carpet nearside front footwell Nissan ECCSGeneralInside car under centre console Nissan
ECCSPrimera TDInside car under centre console Nissan ECCSTino 2.2 DiBehind glove box. Bosch 0281Navara 2.5
DiECU is located in the centre console, it is accessed from both the passengers side and the drivers side, pull back the
carpet and you will see the ECU, it is retained by 10mm nuts We cannot modify the TD model only the Di. NissanECU
Location : PeugeotModelECU LocationOBD LocationECU ID Code106/306Under bonnet nearside of engine bayUnder
dashboard (OBD II Port)Bosch 0261/0280/0281 Marelli206Under bonnet offside of engine bayUnder dashboard (OBD II
Port)Bosch 0261205/309Inside car above steering column Bosch 0261/ 0280405/406/806/605Under bonnet offside of
engine bayBehind small panel in dash above left knee when sitting in drivers seat, lever out carefully (OBD II Port) (406
only)Bosch 0261/ 0280307 In panel above right knee when sitting in driver seat, move steering column up to ease access
and undo screw to remove panel (OBD II port) 607 2.2 HDI The location of the 16 pin socket on a Peugeot 607 HDi is in
the arm rest under the trim. You will need a small screwdriver to lift the edge up.Bosch DDE207 GTiThe ECU is located
to the rear of the passenger's side of the engine bay under a plastic coverIn the Glovebox behind a flapBosch
MED17207 1.6 Turbo GT 150bhpThe ECU is located to the rear of the passenger's side of the engine bay under a
plastic cover.In the Glovebox behind a flapBosch MED17ECU Location : PorscheModelECU LocationOBD LocationECU
ID Code911/993Under nearside front seat Bosch 0261/ 0280928/S5/GTSUnder carpet nearside front footwell Bosch 0261/
0280/ 0227944/968Under carpet nearside front footwell Bosch 0261/ 0280/ 951924Inside car under steering
column Bosch 0261996 All models Above drivers feet, OBD2BoschCayenne/997/Boxster/Cayman Above drivers feel,
OBD2Bosch ME7 Above passengers knee.Bosch ME7ECU Location : RenaultModelECU LocationOBD LocationECU ID
CodeClioUnder bonnet in scuttle offside Bosch 0261/ 0281 Renix Bendix19/Laguna/MeganeUnder bonnet offside of
engine bay Bosch 0261/ 0281 Renix Bendix21 TurboUnder bonnet beside battery Bosch 0261/ 0281 Renix BendixGTA
V6Inside car behind rear seats Bosch 0261EspaceUnder bonnet offside of engine bay Bosch 0261/ 0281 Renix
BendixClio2000 onwardsBehind ashtray (OBD II Port)Siemans Sirius 32/DelphiMegane/Scenic2000 onwardsBehind
fusebox cover (OBD II Port)Siemans Sirius 32/Bosch 0281Laguna2000 onwardsBehind ashtray (OBD II Port)Bosch
0281Espace 2.2 DCIon 2005on 150bhp model - ECU under battery - CHIP ONLYPassengers floor under the carpet,
OBD II.Bosch EDC15Megane/Scenic 2 1.9 DCI 120bhpThe ECU is located in the engine bay on the nearside beside the
air filter. Bosch EDC16Megane Sport 225 The OBD11 socket is at the bottom of the dashboard above the centre console,
behind a small panel which unclips easily.Sagem 3000Clio Renaultsport 2.0 16v 197bhp The OBD11 socket is found in
the centre console beneath the slot where the key card is inserted, a small panel must be unclipped to reveal it.Sagem
3000ECU Location : RoverModelECU LocationOBD LocationECU ID CodeMiniUnder bonnet offside of engine bay Lucas
MEMSMetro/111Under bonnet nearside of engine bay Lucas MEMS200 SeriesUnder bonnet nearside of engine
bay Lucas MEMS Bosch 0281 Honda400 SeriesUnder bonnet on firewall behind engine Lucas MEMS Bosch 0281
Honda600 seriesUnder carpet nearside front footwell Lucas MEMS Bosch 0281 Honda800 SeriesUnder bonnet nearside
of engine bay Lucas MEMS Bosch 0281 HondaMGF/VVCIn engine compartment on firewall Lucas MEMSRange Rover
DSEUnder bonnet offside of engine bay Bosch 0281Land Rover Defender TD5Under drivers seat Lucas
MEMSSDI'sUnder bonnet on firewall behind engine Bosch 0281Land Rover Discovery TD5Engine Bay drivers side
behind battery in plastic boxAbove drivers left knee.Lucas Mems25/45 (All models) Driver footwell above left knee.OR on
2000 TD model behind ashtray right at the back, you need to unclip the OBDII port from it's mountings to access
serially. 75 (All Models) Drivers footwell, above right knee. ECU Location : SaabModelECU LocationOBD LocationECU ID
CodeAPCUnder bonnet nearside of engine bay Bosch 0261/ 0280900/9000Inside car on offside A post Bosch 0261/
02802.3DIUnder bonnet nearside below screen Bosch 0261/ 0280 Inside car below steering column Bosch 0261/
0280 Under nearside front seat Bosch 0261/ 02809-3/9-5 All Serial Cars Above drivers footwellSaab93 115bhpThere is a
hybrid ECU on the fuel pump, but the EDC15 unit is behind the glovebox. 0281...93 125bhp >2000Cannot be modified. 9-
3 1.9TiD 120bhp Z19DTBehind offside front wheel arch. Bosch EDC1693 1998cc 2.0 T 150/175/210bhp 2002 on The
OBD Port is located below the steering wheel in the dashboard.Trionic 89-51.9TiD 150bhp Z19DTPassenger side,
beneath scuttle panel underneath wipers. Bosch EDC16ECU Location : SeatModelECU LocationOBD LocationECU ID
CodeGeneralUnder scuttle trim between wipers Bosch 0261/ 0281Alhambra <2000Behind instraments in facia Bosch
0261/ 0281Alhambra >2000Under bonnet next to batteryAbove pedal assembly (throttle)Bosch 0261 / 0281Ibiza 1.9L
100PD Above right knee behind storage tray. Ibiza 1.9L 130PD Above right knee behind storage tray. Leon 1.9L 110TD At
the bottom of the main centre console behind panel. Arosabeneath weather panel in engine bay passenger sidecentre
console, behind ashtrayBosch'R' 225 Centre console beneath dashboard in storage compartmentBoschECU Location :
SkodaModelECU LocationOBD LocationECU ID CodeGeneralUnder scuttle trim between wipers Bosch 0261/
0281FeliciaUnder bonnet nearside of engine bay Bosch 0261Fabia 1.9L 100PD Above right knee behind storage
tray. Octavia 1.9L 100TD Below the steering wheel at back of shelf. ECU Location : SubaruModelECU LocationOBD
LocationECU ID CodeGeneralUnder carpet nearside front footwell UnisiaECU Location : SuzukiModelECU LocationOBD
LocationECU ID CodeSwiftInside car above pedal assembly NippondensoBalenoBehind glove
box NippondensoCappucinoInside car on nearside A post NippondensoGrand VitaraEngine bay, nearside wing under fluid
bottle and panel beneath.Inside vehicle, drivers side dash above pedal assembly.EDC15C2Vitara 1.9 DDiSOn front right
of the engine bay, laying horizontally. Bosch EDC16ECU Location : ToyotaModelECU LocationOBD LocationECU ID
CodeGeneralInside car under centre console Hitachi Behind glove box HitachiSupra single turboBehind glove
box HitachiSupra twin turboUnder carpet nearside front footwell HitachiMR2In rear boot on firewall HitachiECU Location :
Vauxhall/OpelModelECU LocationOBD LocationECU ID CodeGeneralInside car on offside A postIn fuse box under facia
o/sBosch 0261/0281 DelcoOmegaUnder bonnet nearside of engine bayIn fuse box under facia o/sBosch 0261/
0281VectraUnder bonnet in scuttle nearsideCentre console, under handbrake: pull off plastic cover.Bosch 0261/
0281SintraInside air filter casingUnder facia offsideBosch 026199-2004 Astra G / DI / DTIBehind nearside repeater lamp
under wheelarch linerCentre consoleBosch 0261/ 0281Zafira / DI / DTIBehind nearside repeater lamp under wheelarch
http://www.dnatuning.com Powered by Joomla! Generated: 23 May, 2011, 15:58
DNA Tuning - ECU and Performance Specialists
linerCentre consoleBosch 0261/ 0281FronteraDrivers side 'A' post, passenger footwellBehind coin tray on centre
consoleBosch 0261/0281VX220 Passengers side footwellDelco GM PTAstra H 1.9 CDTi 150bhpBehind nearside front
wheel arch. Bosch EDC16Astra H VXR 237bhp Underneath the handbrake.Bosch 7.6.2Vectra / Signum 2.0 T
175bhp Centre console below the ashtray.Trionic 8Corsa VXR At the bottom of the centre console, OBD2.Bosch
ME7.6.2Signum / Vectra C 2.8 V6 Turbo 230bhp located in the centre console below the ashtray or beneath the
handbrake.Bosch MED9 Vivaro 2.0 CDTi The OBDII socket is located behind a plastic cover beneath the steering wheel,
level with the drivers knee's.Bosch EDC16ECU Location : VolkswagenModelECU LocationOBD LocationECU ID
CodeGeneralUnder scuttle trim between wipers or on nearside Bosch 0261/0281Sharan <2000Behind instraments in
facia Bosch 0261/0281Sharan >2000Under bonnet next to battery Bosch 0261/0281CarravelleIn engine compartment on
nearside Bosch 0261/0281TransporterIn engine compartment on nearside Bosch 0261/0281LTIn engine compartment on
nearside Bosch 0261/02812001 onThe ECU is located under the bonnet on the nearside bulkhead. The ECU is held in a
black cage. Remove the air box and then twist the whole cage clock wise and then unhook it from it's retaining lugs. Heat
the 2 shear bolts up and remove with vice grips Bora 1.9L 100PD Behind the panel at the bottom of the centre
console. Bora 1.9L 150PD Behind the panel at the bottom of the centre console. Golf 1.9L 100PD Behind the panel at the
bottom of the centre console. Golf 1.9L 130PD Behind the panel at the bottom of the centre console. Golf 1.9L
150PD Behind the panel at the bottom of the centre console. Polo 1.4L 75PD Behind the ashtray at the bottom of the
centre console. Polo 1.9L 100PD Behind the ashtray at the bottom of the centre console. Sharan 1.9L 115PD Under
steering wheel above pedal assembly. Sharan 1.9L 130PD Under steering wheel above pedal assembly. Beetle All
modelsUnder dashboard, under the pollen filter inside the car. Bosch ME7Golf Mk5 2.0l TDI 140bhpRemove windscreen
wipers, then scuttle panel. Remove large panel insert in middle of bulkhead. ECU behind metal cover (sheer bolts to
remove) in middle of scuttle area. The ECU connector will be very stiff as it is siliconed shut. Bosch EDC16Touareg 5.0l
V10 TDIThis car uses a Bosch EDC16 ECU. There are two ECU's, to access both ECU's the windscreen wipers must be
disconnected so the weather panel can come off. The offside ECU is just below where the driver's windscreen wiper
locates and the ECU simply unclipsThe second ECU is located just off centre on the nearside; it is mounted vertically and
must be un-clipped to disconnect the loom. NB: a puller is required to remove the windscreen wipersBosch EDC161.6
FSI 115bhpBehind scuttle panel in centre Bosch MED92.0l FSI 150bhpBehind scuttle panel in centre. Bosch MED9Golf
GTI 2.0l T FSI 197bhpBehind scuttle panel in centre. Bosch MED9Transporter 2.5 TDIUnder battery, remove black plastic
panel, ECU underneath. Bosch EDC162005 Passat 2.0l TDI 140bhpBehind scuttle panel in the middle, you will need to
remove the windscreen wipers. Siemens PPDPhaeton 3L V6 TDIThe windscreen wiper mechanism has to be removed
along with all the scuttle panels. ECU located behind scuttle panel. Bosch EDC16Touran Behind the storage tray beneath
the wteering wheel to the right hand side.Bosch EDC16U1Touareg (all models) The OBD11 Port can be found above the
pedal assembly in the fascia. LT 35 2.8Behind lower panel / trim beneath dashboard in fron of the gear stick. BoschECU
Location : VolvoModelECU LocationOBD LocationECU ID Code440/460/480Inside car on offside A
post SiemensV40/S40 T4Inside car in front of centre console SiemensV70/S70/C70Under bonnet offside of engine
bay Bosch 0261/0281 Siemens740/850/940/960Under bonnet offside of engine bay Bosch 0261/0281 Siemens2001/2002
V40 1.8 TDIOffSide chassis leg under the bonnet. Remove the underbelly cover panel, ECU behind. Bosch 0281XC90
T6The ECU is located behind driverside headlight. The purple tabs require to be pushed towards headlight. Bosch ME7