Вы находитесь на странице: 1из 2

Review Electric Forces and Electric Fields

1. Charges are quantized, discrete and 
Final Exam conserved.
2. Like charges repel, unlike attract.
1. Thursday 5/26, 6:00‐8:00 PM, same room. 3. Coulomb’s law.
4 Electric field = force/charge
4. Electric field = force/charge
2. Seven or eight questions from Chapters 19‐‐31 except 27, 29. 
5. Superposition of forces and fields.
3. Equation sheet will be provided.  Bring calculators. 6. Conductors: zero field inside, field  A small 2.00‐g plastic ball is 
perpendicular to surface, charge on  suspended by a 20.0‐cm‐long string in 
surface, more at sharp corners. a uniform electric field, as shown in 
this figure. If the ball is in equilibrium 
7. Gauss’s law. when the string makes a 15.0° angle 
with the vertical as indicated, what is 
the net charge on the ball?

Electric Energy and Capacitance Current and Resistance

1. Difference in electric potential. 1. Electrical current, drift velocity.
2. Electric potential due to a point charge. 2. Resistance.
3. Superposition of potential due to multiple charges.
4. Capacitance. 3. Ohm’s law.
5. Energy stored in capacitor. 4. Resistivity
6 Capacitance in parallel and in series
6. Capacitance in parallel and in series.
5. Power.

A 4.00‐kg block carrying a charge Q = 50.0 μC is 
connected to a spring for which k = 100 N/m. The 
block lies on a frictionless horizontal track, and the 
system is immersed in a uniform electric field of  A particular wire has a resistivity of 3.0 × 10−8 Ω ∙ m and a cross‐sectional 
area of 4.0 × 10−6 m2. A length of this wire is to be used as a resistor that 
magnitude E = 5.00 × 105 V/m directed as in the 
will develop 48 W of power when connected across a 20‐V battery. What 
figure. (a) If the block is released at rest when the 
length of wire is required?
spring is unstretched (at x = 0), by what maximum 
amount does the spring expand? (b) What is the 
equilibrium position of the block?

Direct Current Circuits Magnetism
1. Magnetic force on moving charge.
1. emf 2. Magnetic field
2. Internal resistance of battery. 3. Force on conductor carrying current.
3. Resistors in series and in parallel. 4. Torque on current loop.
4. Equivalent resistance. 5. Ampere’s law
5. Kirchhoff’s rules: junction rule  6. Forces between parallel wires carrying 
and loop rule current.
6. RC circuits. 7. Solenoid
Two long parallel conductors separated by 10.0 cm carry currents in the 
Suppose that the switch has been closed  same direction. The first wire carries a current I1 = 5.00 A and the second 
for a length of time sufficiently long for the  carries I2 = 8.00 A. (a) What is the magnitude of the magnetic field 
capacitor to become fully charged. Find (a)  created by I1 at the location of I2? (b) What is the force per unit length 
the steady‐state current in each resistor  exerted by I1 on I2? (c) What is the magnitude of the magnetic field 
and (b) the charge on the capacitor. created by I2 at the location of I1? (d) What is the force per length 
exerted by I2 on I1?

1
Alternating Current Circuits 
Induced Voltages and Inductance
and Electromagnetic Waves
1. Magnetic flux
1. Maximum voltage/current and rms
2. Faraday’s law of induction voltage/current.
3. Lenz’s law and motional emf 2. Capacitive and inductive 
reactances.
4. Generators and motors
3. Impedance of LCR circuits.
5
5. Self‐induction and Inductance
Self‐induction and Inductance
4. Phase angle and power factor.
6. RL circuit
5. Resonant frequency.
7. Energy stored in inductor
6. Electromagnetic waves.
The square loop is made of wires with a total series 
resistance of 10.0 Ω. It is placed in a uniform 0.100‐T  Two connections allow contact with two circuit elements in series inside a box, but it is not 
magnetic field directed perpendicular into the plane of the  known whether the circuit elements are R, L, or C. In an attempt to find what is inside the box, 
paper. The loop, which is hinged at each corner, is pulled as  you make some measurements, with the following results: when a 3.0‐V DC power supply is 
shown until the separation between points A and B is 3.00 m.  connected across the terminals, a maximum direct current of 300 mA is measured in the circuit 
If this process takes 0.100 s, what is the average current  after a suitably long time. When a 60‐Hz source with maximum voltage of 3.0 V, is connected 
generated in the loop? What is the direction of the current? instead, the maximum current is measured as 200 mA. (a) What are the two elements in the 
box? (b) What are their values of R, L, or C?

Reflection and Refraction of Light Mirrors and Lenses

1. Nature of light 1. Real and virtual images

2. Law of reflection 2. Magnification of mirrors and lenses

3. Index of reflection 3. Focal length of mirrors and lenses

4. Law of refraction, Snell’s law 4. Mirror equation, thin lens equation

5. Huygens’s principle
6. Total internal reflection and critical  In a darkened room, a burning candle is placed 1.50 m 
angle from a white wall. A lens is placed between candle and 
wall at a location that causes a larger, inverted image to 
form on the wall. When the lens is moved 90.0 cm 
A beam of light both reflects and refracts at the surface  toward the wall, another image of the candle is formed. 
between air and glass. If the index of refraction of the glass is  Find (a) the two object distances that produce the 
ng, find the angle of incidence, θ1, in the air that would result  images just described and (b) the focal length of the 
in the reflected ray and the refracted ray being perpendicular  lens. (c) Characterize the second image.
to each other.

Wave Optics Quantum Physics and Atomic Physics
1.  Interference needs coherent source
1. Blackbody radiation and Planck’s hypothesis
2. Young’s double‐slit experiment
2. Photoelectric Effect
3. Diffraction, single‐slit diffraction
3. The de Broglie wavelength and matter wave
4. Diffraction grating
4. The Bohr model of hydrogen atom and quantum numbers
5. Phase change due to reflection
5
5. Atomic transitions
Atomic transitions
6. Thin film interference
7. Polarization Thin film:
Polarization: I = I0 cos2θ
KEmax = h f – φ (a) Find the wavelength of the emitted photon 
A screen is placed 50.0 cm from a single slit, which is illuminated with light of wavelength 680  2 d sinθ = mλ when an electron in a hydrogen atom makes a 
transition from energy level 2 to 1.  (b) If this 
nm. If the distance between the first and third minima in the diffraction pattern is 3.00 mm, 
what is the width of the slit?
λ= h/p = h/(mv) photon is incident on a material and the 
Εn = -13.6/n2 eV photogenerated electron has a maximum KE of 
1.22 eV, find the work function of this material.
Light of intensity I0 and polarized parallel to the transmission axis of a polarizer, is incident on an 
analyzer. (a) If the transmission axis of the analyzer makes an angle of 45°with the axis of the 
h f = Ei – Ef
polarizer, what is the intensity of the transmitted light? (b) What should the angle between the 
transmission axes be to make I/I0 = 1/3?

Вам также может понравиться