Академический Документы
Профессиональный Документы
Культура Документы
4.6.2 "The entire screen does not light (No Picture)” Problem analysis procedure
Y
Remove CN6
(on LOGIC Board,
PSU-LOGIC cable)
Turn on AC power.
XSUS
CN22 CN23 X-SUS board
[XSUS - YSUS] [XSUS - PSU] CN23 (3)-(4) pins or Y X-SUS board is
-Vs
13
Vs
10
CN23 (8)-(6) pins or defective.
12 9
-Vs Vs
8
CN22 (10)-(13) pins
11
NC Vs are shorted.
10
NC
7 Switching circuit (power
GND
NC
9
GND
6 supply) has a short-circuit.
8 5
Vu GND
7 4 N
NC GND
6 3
Vcc Vcc
5 2
NC NC
4 1
GND Va
NC
3 Turn off the AC power,
Vs
2
End of analysis
Vs
1
(1)
SDRU (1)
On CN801 on SDRU,
or CN811 on SDRD, Y
short circuit in following SDU or D is
connection? defective
(2)-(6), (20)-(24),
(28)-(30), (46)-(50)
SDRD
N
X-BUS board Y
ANALYSIS OPERATION WITHOUT POWER SUPPLY
CN63 (1)-(9)
are shorted.
X-BUS Y
board X-BUS board is
CN63 (1)-(9) defective.
N
X-BUS Y
board
CN63 (1)-(9)
N X-SUS board
is defective.
X-BUS board
is defective.
PANEL chassis
is defective.
(2)
TROUBLESHOOTING THE 50AE1 PANEL
ADM* (Connector with COF attached)
COF (Chip on Film)
(2)
COF COF
On ABUSL board Y
Connector to ABUS PWB
CNL2 (14)-(19) pin or
CNL2 (14)-(15) pin
are shorted.
Remove ADM* from the following
four connectors.
N CNL 3, CNL 4,CNL 5, CNL 6
ABUSL board
CN52 (14)-(19) pin
N ADM is defective
or (Panel chassis is defective.)
CN52 (14)-(15) pin
ADM chip is defective
Y
ABUSL board is defective.
ANALYSIS OPERATION WITHOUT POWER SUPPLY
ABUSR board
CNR3 (6)-(5) pins or Y
CNR3 (6)-(1) pins
are shorted. ADM (Connector with COF attached)
ABUSR board
N ADM is defective
CNR3 (6)-(5) pins or
CNR3 (6)-(1) pins (Panel chassis is defective.)
are shorted.
ADM chip is defective
Y
ABUSR board
is defective.
ABUSC board
CNC3 (6)-(5) pins or
Y
CNRC (6)-(1) pins
ADM (Connector with COF attached)
are shorted.
ABUSR board
CNR3 (6)-(5) pins or
N ADM is defective
CNR3 (6)-(1) pins (Panel chassis is defective.)
are shorted.
ADM chip is defective
Y
ABUSC board is defective.
End of analysis
(3)
(3)
Connect CN23(X-SUS),
CN32(Y-SUS), and
Vsago turns on
exist ?
Y
PSU board N
Vcc(5V), Va (65V) SDR U or D board is defective
exists ?
Y
Turn off AC power. YFPC or Panel is defective
Connect CN 26 (X-SUS).
Vsago turns on
Y
On PSU board N ABUSR board is defective.
Va (65V) exists ?
Y
ADM is defective
(Panel chassis is defective.)
(4)
Turn off AC power, End of analysis
(3)
Y
On PSU board N
Va (65V) exists ? ABUSC board is defective
ANALYSIS OPERATION WITH POWER SUPPLY
On PSU board N
ABUSL board is defective.
Va (65V) exists ?
Y
ADM is defective
(Panel chassis is defective.)
Analysis is over