Вы находитесь на странице: 1из 1

www.installdr.

com

General Motors Radio Wire Harnesses


Up To 1989-1990
Pin Either a 2 wire Connector
M N

What It Is Right Rear Spkr (-) Left Rear Spkr (-) Right Rear Spkr (+) Left Rear Spkr (+) Left Front Spkr (+) Right Front Spkr (+) Left Front Spkr (-) Right Front Spkr (-) Power Antenna Turn On +12 Volt Ignition Wire Headlight Dimmer Wire Ground Wire +12 Volt Battery Wire Not Used

Typical GM Factory In Dash Wire Color Light Blue Yellow Dark Blue Brown Tan Light Green Light Gray Dark Green Pink (if available) Yellow Gray Black Orange Not used

Typical New Radio Equivalent Wire Color Purple w/ Black Stripe Green w/ Black Stripe Purple Green White Gray White w/ Black Stripe Gray w/ Black Stripe Blue Red Orange (if available) Black Yellow

A C

B D

E G

F H

I K

J L

Or a 3 wire Connector Blue White Black


M N O

AS VIEWED FROM MATING END OF CONNECTOR

A B C D E F G H I J K L M N

1989-1990 And Newer


Pin A B C D E F G H I J K L M N What It Is Left Front Spkr (-) Left Front Spkr (+) Right Front Spkr (-) Right Front Spkr (+) Ground Wire Not Used Headlight Dimmer Wire Power Antenna Turn On +12 Volt Ignition Wire +12 Volt Battery Wire Right Rear Spkr (-) Right Rear Spkr (+) Left Rear Spkr (-) Left Rear Spkr (+)

Typical GM Factory In Dash Wire Color Light Gray Tan Light Green Dark Green Black Gray Pink (if available) Yellow Orange Light Blue Dark Blue Yellow Brown

Typical New Radio Equivalent Wire Color White w/ Black Stripe White Gray w/ Black Stripe Gray Black Orange (if available) Blue Red Yellow Purple w/ Black Stripe Purple Green w/ Black Stripe Green

AS VIEWED FROM MATING END OF CONNECTOR

Standard sized antenna cable and connector

Smaller sized antenna cable and connector found on 1989 and newer General Motors vehicles

Publication, Duplication, or Retransmission Of This Document Not Expressly Authorized In Writing By The Install Doctor Is Prohibited. Protected By U.S. Copyright Laws. 1997,1998,1999,2000.
All Information, Including Photos And Illustrations, In These Pages Is Believed To Be Correct And Reliable. The Information Contained In These Pages Is Given As General Information For The Installation Of Audio, Video, Security, Communications, And Other Accessory Products Into Mobile And/Or Vehicle Applications. The Install Doctor, Any Subsidiaries Or Divisions Thereof, Or Any Member Of These Companies Shall Not Be Held Liable For Any Damages And/Or Injuries Resulting From The Use Of Information Contained In These Pages. All Information Contained In These Pages Should Be Checked And Verified With Appropriate Test Equipment To Assure The Safety And Proper Operation Of Equipment Installed And The Vehicle Itself. Careful Attention Should Be Given To All Electronic/Electric Circuits. High Voltages And Currents Can Cause Bodily Injury, Skin Damage, And Even Death. Installs Are Taken At The Risk Of Each Installer, And/Or Individual.

Вам также может понравиться