Академический Документы
Профессиональный Документы
Культура Документы
15220
Application Data
29-167J
Page 1
Breaker Description
Series C Types JDB, JD, HJD Equipped With Type JT Thermal-Magnetic Trip Unit ............................................................. SC-4247-87C Series C Types JDC Equipped With Type JT Thermal-Magnetic Trip Unit ............................................................. SC-4248-87B
Individual oversize copies of curves listed above printed on onion-skin paper are available in limited quantity from: Cutler-Hammer Westinghouse & Cutler-Hammer Products Five Parkway Center Pittsburgh, PA 15220 When ordering onion-skin curves, use number at bottom of page where curve appears, i.e., SC-4547-87B. Requests for full sets of curves will not be honored.
Application Data
29-167J
Page 2
2000
3000
4000
5000
60 70 80 90 100
200
300
400
500
50
20,000
30,000
40,000
50,000
10,000
10,000
2 HOURS
2 HOURS
Series C J-Frame Circuit Breakers Equipped with Type JT Thermal-Magnetic Trip Unit
Catalog Types JDB, JD, HJD Circuit Breakers, 2, 3 and 4 Poles For application and coordination purposes only. Thermal calibration based on 40C ambient, cold start. Connected with four (4) feet of rated wire (60C up to 125 amps, 75C above 125 amps) per terminal. Tested in open air with current in all poles. Instantaneous calibration based on single-pole tests. Maximum Voltage 600 V., Ac (50/60 Hz.) 250 V., Dc Breaker Rating Rated Amperes (In) Instantaneous Trip Amperes (See Figure Below) 500 to 1000% of trip unit rating. (Dc values are approximately 40% higher)
5,000
1 HOUR
1 HOUR
3,000
3,000
2,000
2,000
1,000
1,000
500
(250A)
70, 90, 100, 125, 150, 175, 200, 225, 250 Interrupting Rating
500
300
(125-225A)
200
300
UL/CSA RMS Sym. kA, 50/60 Hz. 480 V. 35 65 35 65 65 100 IEC 157-1 (P1) RMS Sym. kA, 50/60 Hz. 240 V., (Ue) 380 V., (Ue) 35 35 65 65 65 100 240 V. 600 V. 18 18 25
kA, Dc 250 V. 10 10 22
100
200
(70-100A)
100
1 MINUTE
1 MINUTE
50
Minimum
Maximum
JDB JD HJD
20
Single pole test data at 25C based on NEMA Procedures (AB 4-1991) for verifying performance of molded case circuit breakers.
7.5 7.5 Push to Trip 7.5
30
20
10
10
10
Magnetic Multiples Of In
40C
Cat. No.
TIME IN SECONDS
TIME IN SECONDS
.3
10X
5X
.5
20%
10%
.5
.3
.2
.2
.1
.1
.05
.05
.03
.03
.02
.02
.01
.01
.005
.005
.003
.003
.002
.002
20,000
30,000
40,000
50,000
60
70 80 90 100
50
.001
.001
500
200
300
400
2000
3000
4000
5000
December 1998
Application Data
29-167J
Page 3
2000
3000
4000
5000
60 70 80 90 100
200
300
400
500
50
20,000
30,000
40,000
50,000
10,000
10,000
2 HOURS
2 HOURS
1 HOUR
Series C J-Frame Circuit Breakers Equipped with Type JT Thermal-Magnetic Trip Unit
Catalog Type JDC Circuit Breakers, 2, 3 and 4 Poles
5,000
1 HOUR
3,000
3,000
2,000
For application and coordination purposes only. Thermal calibration based on 40C ambient, cold start. Connected with four (4) feet of rated wire (60C up to 125 amps, 75C above 125 amps) per terminal. Tested in open air with current in all poles. Instantaneous calibration based on single-pole tests. Maximum Voltage 600 V., Ac (50/60 Hz.) 250 V., Dc Breaker Rating Rated Amperes (In) Instantaneous Trip Amperes (See Figure Below) 500 to 1000% of trip unit rating. (Dc values are approximately 40% higher)
2,000
1,000
1,000
500
(250A)
500
300
(125-225A)
Interrupting Rating Breaker Type JDC UL/CSA RMS Sym. kA, 50/60 Hz. 240 V. 480 V. 200 100 IEC 157-1 (P1) RMS Sym. kA, 50/60 Hz. 240 V., (Ue) 380 V., (Ue) 100 200 600 V. 35 kA, Dc 250 V. 22 kA, Dc 415 V., (Ue) 100 250 V., (Ue) 22
300
200
200
(70-100A)
100
100
1 MINUTE
1 MINUTE
Minimum
50
Maximum
JDC Notes
For additional information on the trip unit, see IL 29C600. For I2t, Ip and threshold values, see AD 29-166.
Single pole test data at 25C based on NEMA Procedures (AB 4-1991) for verifying performance of molded case circuit breakers.
7.5 7.5 7.5
50
30
30
20
20
10
Push to Trip
10
10
Magnetic Multiples Of In
40C
Cat. No.
TIME IN SECONDS
TIME IN SECONDS
.3
10X
5X
.5
20%
10%
.5
.3
.2
.2
.1
.1
.05
.05
.03
.03
.02
.02
480 V., Ac
.005 .005
240 V., Ac
.003 .003
.002
.002
20,000
30,000
40,000
50,000
60 70 80 90 100
50
.001
.001
500
200
300
400
2000
3000
4000
5000
December 1998
Application Data
29-167J
Page 4
Cutler-Hammer Westinghouse & Cutler-Hammer Products Five Parkway Center Pittsburgh, Pennsylvania, U.S.A. 15220
Printed in U.S.A.
December 1998