Академический Документы
Профессиональный Документы
Культура Документы
Page 1 of 2
http://127.0.0.1:43231/NED/NED?service=printview&library=a25002a0000a0310176p1&... 7/12/2011
Page 2 of 2
in response to the last pilot bits transmitted prior to the transmission gap is applied to uplink DPCCH power calculation. Alternative scrambling code can be used for DPCH only. Compressed Mode: Alternative scrambling code (AltScramblingCodeCM) parameter defines whether the alternative scrambling code is allowed to be used in case of compressed mode method halving the spreading factor. Note: If there are NBxxx's with CHC48 plug in unit configuration connected to the RNC, then configured values of the all TGPL* parameters are equal. While compressed mode is active, HSDPA (HS-DSCH/DCH) can be allocated, released or reconfigured as follows: Allocation can be triggered based on capacity requests or because of channel type switch criteria. Release or reconfiguration as DCH/DCH x/x kbps configuration is allowed because of any reason. During the allocation, release or reconfiguration, compressed mode is modified based on corresponding DCH compressed mode parameters. Compressed mode is stopped if the release of the HSDPA results in an RRC connection ends with an SRB only, that is DCH/DCH 0/0 kbps configuration. The DCH uplink channel of an HS-DSCH/DCH configuration can be reconfigured while HSPA compressed mode is active. Inter-frequency handover measurements itself continue without changes when compressed mode changes from HSDPA compressed mode to DCH compressed mode or vice versa. HSPA (HS-DSCH/E-DCH) is not allocated while compressed mode is active. PS RABs can be reconfigured during HSDPA compressed mode and the reconfiguration of SPI because of PS RAB reconfiguration is supported.
DN03471612
Id: 0900d80580749b8d
http://127.0.0.1:43231/NED/NED?service=printview&library=a25002a0000a0310176p1&... 7/12/2011