Академический Документы
Профессиональный Документы
Культура Документы
Version : R6.1
www.Prepking.com
www.Prepking.com
1. HP Ultrium tape drives use the ATS (Adaptive Tape Speed) feature. The main purpose of ATS is to increase ____. A. buffer capacity by varying the speed of the tape B. tape write speed by adjusting the host transfer rate C. overall performance by reducing the number of repositions D. tape read speed by adjusting the host transfer rate Answer: C
2. What is the maximum cable length of an LVD SCSI bus? A. 7 m B. 12 m C. 20,5 m D. 25 m Answer: B
3. What happens if you connect an HVD (High Voltage Differential) HBA (host bus adapter) to an LVD (Low Voltage Differential) tape device? A. The devices function correctly if you setup unique SCSI IDs and have proper termination. B. The devices do not function together and you may damage them. C. The devices function correctly after setting up the compatibility mode for the HBA. D. The devices do not function together unless you use active termination. Answer: B
4. What is an advantage of the Cartridge Memory (a memory chip located in the cartridge) of the LTO Ultrium technology (LTO-CM) over previous tape technologies? A. It eliminates the need for barcodes and barcode readers in tape libraries. B. Data such as tape identity, type, usage and tape contents is read from a chip rather than the system area on tape, which reduces the wear and tear of that particular section. C. It contains troubleshooting information from the tape drive which can help to reduce overall repair times. D. The Ultrium drive reads data for firmware upgrades from a chip rather than a tape which increases the
www.Prepking.com
5. The DLT tape backward read compatibility of HP SuperDLT drives is possible due to the ____. A. Magneto-Resistive Cluster (MRC) technology B. additional magnetic read-head C. Pivoting Optical Servo (POS) technology D. low-dens mode switch Answer: B
6. SCSI bus termination is ____. A. optional B. required and there must be one terminator for each device on the bus C. required and there must be two terminators, one on each end of the bus D. required and done automatically by all SCSI devices Answer: C
7. Which tool, available at the HP web site, can size and configure the ideal backup solution for DAS, NAS and SAN environments using information you specify? A. HP OpenView Data Protector configuration scripter B. Backup Sizing Tool C. Enterprise Backup Solution Configuration Matrix D. HP StorageWorks Library and Tape Tools Answer: B
8. Which HP StorageWorks tape drive is the most appropriate choice for enterprise businesses with 150 GB of data to backup? A. DAT 24 B. DAT 72 C. DLT VS 80
www.Prepking.com
9. Click the Exhibit button. A customer has one single ESL9326D/DX with 4 DLT8000 drives. Which tape drive is supported for the next drives being installed in this library?
A. DLT 8000 drives only B. SDLT220 or SDLT320 C. DLT8000, SDLT220 or SDLT320 D. SDLT220, SDLT320 or Ultrium230 Answer: C
10. Click the Exhibit button. A customer installed Virtual Replicator on a Windows 2000 host. Which backup applications are supported for backing up the Virtual Replicator disks? Select TWO.
www.Prepking.com
A. HP Data Protector B. Legato Networker C. Tivoli Storage Manager D. CommVault Galaxy E. CA BrightStor EB Answer: BC
11. Click the Exhibit button. Which library and tape drive firmware must be used for an ESL9322 with Ultrium 460 tape drives and Data Protector?
www.Prepking.com
A. Robot firmware 3.40, tape drive firmware F43W B. Robot firmware 3.48, tape drive firmware F43W C. Robot firmware 3.48, tape drive firmware F3CW D. Robot firmware 3.40, tape drive firmware F3CW Answer: B
12. A medium business with small workgroups and remote offices needs to backup about 40 GB of data. Which HP StorageWorks tape drive is the most appropriate? A. DAT 24 B. DAT 72 C. Ultrium 460 D. SDLT 320 Answer: B
13. Which file types should NOT be selected for backup in compressed mode? Select THREE. A. Exchange Server stores B. MPEG files
www.Prepking.com
C. Powerpoint presentations D. JPEG files E. ASCII (.TXT) files F. Post script (.PRN) files Answer: ABD
14. Disk and tape speed are key factors of a fast backup. Which issue may cause slow backup performance on Veritas Netbackup if you are doing LAN-based backup? A. Single mode cables are used instead of multimode cables. B. There are DNS resolution delays and wrong entries in the HOSTS file. C. Fibre Channel switch cannot be reached over LAN. D. Primary and secondary devices are connected to the same switch. Answer: B
15. Which service should be disabled on Windows systems at operating system level to improve backup performance? A. Logical Disk Manager B. Removable Tape Service C. Removable Storage Manager D. Tape Storage Provider Answer: C
16. To determine the scope of a customer problem, you must first ____. A. remove all suspected components and replace them B. consider what may have changed before the fault occurred C. reboot the whole environment D. trust what the customer tells you Answer: B
17. Where do you find the currently loaded driver information in a Windows 2000 environment to allow you
www.Prepking.com
to compare it with the correct downloaded version from HP? A. winnt/system32/etc B. winnt/system/drivers C. winnt/system32/drivers D. windows/program files/drivers Answer: C
18. Which application parameters can increase backup performance? Select THREE. A. buffering efficiency B. software compression ratio C. file size D. block size E. I/O bandwidth F. number of enabled threads Answer: ADF
19. A customer runs a backup. During the backup, the involved disks have a high I/O load. The tape drive is NOT in streaming mode. How can you increase the bandwidth of the disks? Select TWO. A. Increase the number of disks in the RAID array. B. Use network teaming. C. Change the RAID level of the array. D. Modify the zoning on the Fibre Channel (FC) switch so that all FC ports of the primary storage system reside in the same zone as the FC ports of your library/storage router. E. Change the SCSI Command Console LUN on the primary storage from SCSI-2 to SCSI-3. Answer: AC
20. An external Ultrium 230 drive fails to unload using the normal unload procedure. It is not possible to reboot the host at this time. What must you do to resolve the problem? A. Press and hold the eject button on the front of the drive to perform an emergency unload. B. Power off the drive, disconnect it from the SCSI bus, manually remove the cartridge and reconnect the
www.Prepking.com
drive to the SCSI bus. C. Power off the drive, disconnect it from the SCSI bus and replace it with a new one. D. Without powering off the drive or host, use the emergency reset button on the front of the drive, and wait up to 7 minutes for the drive to get to the loaded position. Answer: A
21. A customer's tape device, with hardware compression enabled, is experiencing a loss in the expected capacity. What is the most likely cause? A. The wrong termination is used. B. Connection to the device is loose. C. There is a bent pin in the connection to the drive. D. The source data consists of zipped or audio files. Answer: D
22. Modification of which key factors can cause an increase in the backup performance? Select THREE. A. number of disks B. amount of writeback cache on the disk storage subsystem C. disk speed D. RAID level E. number of tape cartridges used for the backup F. disk size Answer: ACD
23. The front panel LEDs of an HP StorageWorks DAT 72 display: Tape=OFF, Clean = ON steady. What does this represent? A. cartridge loaded, drive ready B. cartridge loaded, self-test in progress C. tape in disaster recovery mode D. hard error during power-on self-test Answer: D
www.Prepking.com
100% Pass Guaranteed or Full Refund Word to Word Real Exam Questions from Real Test Buy full version of exam from this link below http://www.prepking.com/HP0-244.htm