Академический Документы
Профессиональный Документы
Культура Документы
1
I B.Tech Supplimentary Examinations, Aug/Sep 2008
ELECTRICAL AND ELECTRONICS ENGINEERING
(Bio-Technology)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
1. (a) A voltage wave form shown in the figure 1a is applied to a pure resistance of
40 Ω.
Sketch the wave form of the current passing through the resistance.
Figure 1a
(b) Solve the network shown in the figure 1b below for currents in the various
resistors.
[6+10]
Figure 1b
2. (a) Explain the constructional details of a synchronous machine giving the reasons
for making two types of rotors.
(b) Explain auxiliary motor starting of synchronous motors. [6+10]
3. (a) For the network shown in the figure 3(a)i determine the range of RL and IL
that will result in VRL being maintained at 10 V.
1 of 3
Code No: RR12302 Set No. 1
i. Determine the maximum Wattage rating of the diode.
Figure 3(a)i
ii. The reverse saturation current of the diode is 1 µA. Its peak inverse Volt-
age is 500V. Find ri , Vo that PIV is not exceeded. show in figure 3(a)ii &
figure 3(a)ii
Figure 3(a)ii
Figure 3(a)ii
2 of 3
Code No: RR12302 Set No. 1
4. (a) What do you mean by regulation and explain how a full wave rectifier is used
for it.
(b) Compare center tapped transformer and ordinary transformer. What is the
difference in their construction?
(c) Mention the applications of rectifiers in detail. [6+5+5]
6. (a) Draw the circuit diagram of an emitter follower circuit and its h-parameter
model.
(b) For the given component values Rs = 1KΩ, RL = 3 KΩ and for the given h-
parameters hf e = 100, hie = 2KΩ, hre = 2.5 × 10−4 , hoe = 10µA/V. Calculate
AI , RI , Avs and R0 . [6+10]
7. (a) What kind of feedback is incorporated in the Wien bridge oscillator circuit
and why?
(b) In a colpitts oscillator using FET, the frequency of oscillations is observed to
be 2.5 MHz. Oscillator uses L=10 µH, C1 = 0.02 µF. Find
i. the value of C2
ii. If L is doubled the new value of frequency oscillations.
(c) Explain about the applications of OP-AMPs. [4+6+6]
⋆⋆⋆⋆⋆
3 of 3
Code No: RR12302 Set No. 2
I B.Tech Supplimentary Examinations, Aug/Sep 2008
ELECTRICAL AND ELECTRONICS ENGINEERING
(Bio-Technology)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
Figure 1b
2. (a) Explain the process of voltage build up in a self-excited D.C machine.
(b) List out the various conditions to be satisfied for voltage build up process in
a self-excited machine, and write down remedies if the conditions fail. [8+8]
4. (a) The half wave rectifier shown in the figure 4a is fed with a sinusoidal voltage
V=20 sin100t.
i. Sketch the output waveform.
ii. Determine the DC output voltage assuming ideal diode behaviour.
iii. Repeat the calculations assuming the simplified diode (silicon) model.
1 of 3
Code No: RR12302 Set No. 2
Figure 4a
(b) Draw the circuit diagram of full wave rectifier having two diodes and explain
its operation. [8+8]
5. (a) Sketch the input and output characteristics of CB configuration for an n-p-n
transistor, Explain the shape of the curves qualitatively.
(b) For the circuit in figure 5b shown if α = 0.98 VBE = 0.7 V find R1 in the
circuit for an emitter current of IE = -2 mA. Neglect the reverse saturation
current.
[8+8]
Figure 5b
6. (a) Compare the three transistor amplifier configurations with related to AI , Av ,
Ri and R0 .
(b) For the circuit shown calculate AI , AV , Ri and R0 using approximate
h-parameter model. Assume hf e = 50, hie = 1100 Ω, hoe = 25 µA/V, hre =
2.5 × 10−4 as shown in the figure 6b. [16]
2 of 3
Code No: RR12302 Set No. 2
Figure 6b
7. Define the following terms with reference to OP-AMPs:
8. (a) Explain with a block diagram the major blocks of a digital computer.
(b) Implement the following with either NAND or NOR gates. Use only 4 gates
only the normal inputs are available.
F = w′ xz + w′ yz + x′ yz′ + wxy′ z.
(c) With a circuit diagram, explain Counter type A to D converter. [4+6+6]
⋆⋆⋆⋆⋆
3 of 3
Code No: RR12302 Set No. 3
I B.Tech Supplimentary Examinations, Aug/Sep 2008
ELECTRICAL AND ELECTRONICS ENGINEERING
(Bio-Technology)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
1. (a) Determine the effective resistance between the nodes A and B in the circuit
shown in the figure 1a (all values are in ohms).
Figure 1a
(b) Find the Vc and IL from the circuit shown in Figure 1b under steady state
conditions. [10+6]
Figure 1b
2. (a) Name the various parts of a D.C machine and give the materials used for each
part. Also show the magnetic path.
(b) Explain the principle of operation of D.C motor. [8+8]
4. (a) The half wave rectifier shown in the figure 4a is fed with a sinusoidal voltage
V=20 sin100t.
i. Sketch the output waveform.
ii. Determine the DC output voltage assuming ideal diode behaviour.
iii. Repeat the calculations assuming the simplified diode (silicon) model.
1 of 3
Code No: RR12302 Set No. 3
Figure 4a
(b) Draw the circuit diagram of full wave rectifier having two diodes and explain
its operation. [8+8]
Figure 6b
7. (a) Explain the operation of an integrator using OP-AMPs.
(b) Distinguish between positive and negative feedbacks.
(c) List out the characteristics of OP-AMP. [6+4+6]
2 of 3
Code No: RR12302 Set No. 3
8. (a) Convert the following numbers:
i. (1431)10 to base 2.
ii. (53.1575)10 to base 2.
(b) Implement AB+C′ D′ = F with three NAND gates. Draw the logic circuit.
(c) Prove that the NAND Gate is a universal gate.. [8+4+4]
⋆⋆⋆⋆⋆
3 of 3
Code No: RR12302 Set No. 4
I B.Tech Supplimentary Examinations, Aug/Sep 2008
ELECTRICAL AND ELECTRONICS ENGINEERING
(Bio-Technology)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
⋆⋆⋆⋆⋆
1. (a) Determine the effective resistance between the nodes A and B in the circuit
shown in the figure 1a (all values are in ohms).
Figure 1a
(b) Find the Vc and IL from the circuit shown in Figure 1b under steady state
conditions. [10+6]
Figure 1b
2. (a) Describe the construction of a 1-phase transformer and principle of operation.
(b) Write about 3-phase transformer connections. [8+8]
3. (a) For the network shown in the figure 3(a)i determine the range of RL and IL
that will result in VRL being maintained at 10 V.
i. Determine the maximum Wattage rating of the diode.
1 of 3
Code No: RR12302 Set No. 4
Figure 3(a)i
ii. The reverse saturation current of the diode is 1 µA. Its peak inverse Volt-
age is 500V. Find ri , Vo that PIV is not exceeded. show in figure 3(a)ii &
figure 3(a)ii
Figure 3(a)ii
Figure 3(a)ii
4. (a) The half wave rectifier shown in the figure 4a is fed with a sinusoidal voltage
2 of 3
Code No: RR12302 Set No. 4
V=20 sin100t.
i. Sketch the output waveform.
ii. Determine the DC output voltage assuming ideal diode behaviour.
iii. Repeat the calculations assuming the simplified diode (silicon) model.
Figure 4a
(b) Draw the circuit diagram of full wave rectifier having two diodes and explain
its operation. [8+8]
5. (a) Draw the emitter characteristic of UJT and explain the shape of the curve
qualitatively. Mention different regions of operations.
(b) Draw the circuit of a relaxation oscillator and explain its operations. Mention
its applications. [8+8]
⋆⋆⋆⋆⋆
3 of 3