Академический Документы
Профессиональный Документы
Культура Документы
EW1041 Eyewash/Drench Hose Unit, 45 Degree Panel Mounted EW1041BP Eyewash/Drench Hose Unit, 45 Degree Panel Mounted, with Backflow Preventer
wall mounting. Unit meets the provisions of ANSI Z358.1 -2004 as both an eyewash and a drench hose. Unit may be left in the angle holder for use as a fixed eyewash, leaving users hands free. Alternatively, unit may be removed for use as a drench hose to rinse any part of users eyes, face or body.
supply: 3/8" NPT male swivel-type inlet. sign: ANSI-compliant identification sign. quality assurance: Unit is completely assembled and
water tested prior to shipment.
side-by-side. Each head has a flip top dust cover, internal flow control and filter to remove impurities from the water flow.
Available Options
DC Stainless steel dust cover for each spray head. V B In-line vacuum breaker for installation between valve
and spray head.
Flange has handle locator guide to position spray heads and handle facing forward at all times.
hot and cold water to deliver warm (tepid) water as provided by ANSI Z358.1 - 2004. Refer to Tempering Units section for complete technical and product selection information.
ETL Listed 101496. Units have been tested to and comply with ANSI Z358.1 - 2004
EW1041 Eyewash/Drench Hose Unit, 45 Degree Panel Mounted EW1041BP Eyewash/Drench Hose Unit, 45 Degree Panel Mounted, with Backflow Preventer
4 - 1/4" ( 107 mm ) 2 - 5/8" ( 67 mm )
LOCKING CLIP ( 2 ) GS-PLUS SPRAY HEADS
MOUNTING HOLE
DETAIL A
1 - 5/16" ( 33 mm )
STAINLESS STEEL SQUEEZE HANDLE WITH PLASTIC COVER 1" ( 25 mm ) MAX. WALL THICKNESS
1 - 7/8" ( 48 mm )
8" ( 202 mm ) 45
CHROME PLATED BRASS SQUEEZE VALVE WITH REPLACEABLE STAINLESS STEEL SEAT
PLASTIC HOSE GUARD NYLON HANDLE CHROME PLATED BRASS 45 DEGREE ANGLE WALL FLANGE WITH HANDLE LOCATOR 3/8" NPT MALE SWIVEL INLET
8 - 1/4" ( 208 mm )
NOTES: 1. 2.
2 - 1/8" ( 53 mm )
EACH GS-PLUS SPRAY HEAD HAS A FLIP-TOP DUST COVER, INTERNAL FLOW CONTROL AND FILTER TO REMOVE IMPURITIES FROM THE WATER FLOW. HOSE SHOULD NOT BE USED IN APPLICATIONS WHERE WATER PRESSURE EXCEEDS 90 PSI. HOSE SHOULD BE INSPECTED PERIODICALLY FOR DETERIORATION. PROVIDE SUFFICIENT ROOM BEHIND WALL OR PANEL FOR STORING HOSE WHEN UNIT IS NOT IN USE.
3.
Sign Included
Due to continuing product improvement, the information contained in this document is subject to change without notice. All dimensions are 1/4" (6mm). rev. 0308
ETL Listed 101496. Units have been tested to and comply with ANSI Z358.1 - 2004