Вы находитесь на странице: 1из 20

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.

f you acquired this


document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 20




Saturn Securty, Remote Start, Keyess Entry & Navgaton
Wre Coors Verson 4.2









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder on this CD-ROM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 20

Make: Model: Year:
Saturn Coupe 1998-1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH OR FUSE BLOCK
Headlights: D BLUE (LO) & PNK (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module Located Behind Driver Dash. *** f equipped with OEM
alarm you will need a universal alarm bypass module to temporarily bypass the alarm during
remote start. Alternatively you can disarm the alarm with the OEM remote control prior to remote
starting.

Saturn Coupe 1998-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED & RED GNTON SWTCH HARNESS
OEM Alarm Disarm: *** see note
Dome
Lights/Superv:
WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE LOCATED N DRVER'S KCK PANEL ***
Power Unlock: WHTE LOCATED N DRVER'S KCK PANEL ***
Trunk Release: GRAY (+) AT OEM KEYLESS MODULE
Alarm nput Wire: WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **

NOTES: ** WHTE Wire Can Also Be Found n Passenger Side Rear Body Harness Wrapped
With Green Tape. *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 20

Saturn ION 2003-2006

FUNCTON COLOR LOCATON
Start: See Note Below* See Note Below*
gnition #1: Dk. Blue GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: See Note Below* See Note Below*
Accessory: Brown GNTON SWTCH HARNESS
Brake Light: Lt. Blue (+) Above the brake pedal switch
Tach Signal: White (ac) gnition Control Module Above Engine
Parking
Lights:
Brown (+) Found at BCM**
Headlights:
OEM Alarm
Disarm:

OEM Alarm
Arm:

Diesel Glow
Plug:

Clutch
Bypass Wire:

Notes: * The white/black wires found on the Key Sense Module. Two relays and resistors will have to be
obtained. Please call for more notes and information. ** BCM (Body Control Module) located in the
center of the dash, part of the fuse panel.

Saturn ION 2003-2006

FUNCTON COLOR LOCATON
Constant +12
Volts:
Red Found at the BCM**
Starter Kill: See Note Below* See Note Below*
gnition +12
Volts:
Dk. Blue GNTON SWTCH HARNESS
Dome
Lights/Superv:
See Note Below*** See Note Below***
OEM Horn: Black (-) Found at BCM
Power Lock: White (-) Please see note below****
Power Unlock: Single wire (-) Please see note below****
Trunk
Release:

Alarm nput
Wire:
See Note Below*** See Note Below***
Notes:
*** The driver door trigger is lt. green/black. The passenger door is lt. blue, must diode isolate both
wires. These wires are located at the BCM (Body control). **** The Lock wire negative trigger.
Unlock is negative trigger 1.5K ohm resistor. Lock/unlock wire is found at the BCM (Body Control
Module).



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 20
Make: Model: Year:
Saturn L-Series 2000-2002


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HANRESS
gnition #3: GREEN (-) GNTON SWTCH HARNESS **
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: BLUE AT PEDAL OR DRVER'S KCK PANEL
Tach Signal:
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This vehicle is equipped with GM's PASSLOCK Anti-Theft system. See Note #113 -
General Motors PASSLOCK Bypass Diagram. ** This s The Key Sense Wire. t Needs To See
Ground During Remote Start To Prevent ""Service"" Light From Coming On.

Saturn L-Series 2000-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HANRESS
OEM Alarm Disarm:
Dome
Lights/Superv:
SEE NOTE BELOW ***
OEM Horn: LT. BLUE/RED (-) STEERNG COLUMN (AR BAG) HARNESS
Power Lock: ORANGE/BLACK (+) DRVER'S KCK PANEL ****
Power Unlock: RED/BLACK (+) DRVER'S KCK PANEL ****
Trunk Release: BLACK (+) AT SWTCH OR N TRUNK
Alarm nput Wire: SEE NOTE BELOW ***

NOTES: *** GREY/BLACK & BLACK/WHTE AT BCM. CONNECT BOTH WRES AND DODE
SOLATE. **** Positive Pulse Door Lock System. See nstallation Note #202 - Positive Pulse
Door Lock System.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 20

Make: Model: Year:
Saturn L-Series 2003-2005


FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Pink (+) gnition switch harness*
gnition #2: Dk.Green (+) gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Orange (+) gnition switch harness
Brake Light: Lt.Blue (+) Brake pedal switch
Tach Signal: N/A
Parking Lights: Brown (+) Gray plug at the BCM
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *This vehicle is equipped with GM's Passlock Anti-Theft Security System. Use a
universal alarm bypass module.

Saturn L-Series 2003-2005

FUNCTON COLOR LOCATON
Constant +12 Volts: Red (x2) (+) gnition switch harness
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
White (-) Pink plug at BCM
OEM Horn: Black (-) Pink plug at BCM
Power Lock: Red/Black (+) Gray plug at BCM**
Power Unlock: Orange/Black (+) Gray plug at BCM
Trunk Release: Black/White (+) Gray plug at BCM
Alarm nput Wire: White (-) Pink plug at BCM

NOTES: ** See Note #202 Positive trigger door locks



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 20

RELAY 2005

KEY
T-
HARNES
S
MMOBLZER
N/A N/A
GM's PK3 TRANSPONDER ANT-THEFT System, Requires Module and Extra gnition
Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) or RED/BLACK (+) @ BATTERY or FUSE BOX
STARTER YELLOW (+)
GNTON SWTCH HARNESS
or BCM, C1, Pin 21, See NOTE
*1
STARTER 2 N/A
GNTON 1 PNK (+)
GNTON SWTCH HARNESS
or BCM, C1, PN 22, See NOTE
*1
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
GNTON SWTCH HARNESS
or BCM, C1, PN 23, See NOTE
*1
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BROWN/WHTE (-)
@ HEADLGHT SWTCH or
BCM, C3, PN 8, See NOTE *1
PARKNG LGHTS ( + ) BROWN (+)
@ FUSE BOX or PASSNEGER
KCK in harness heading to rear
of vehicle
POWER LOCK ORANGE/BLACK (TYPE B)
@ BCM, C2 Pin 2, See NOTE
*1
POWER UNLOCK ORANGE/BLACK (TYPE B)
@ BCM, C2 Pin 11, See NOTE
*1

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 20

DOOR TRGGER See NOTE *2 @ BCM, C2, See NOTE *1


DOMELGHT SUPERVSON GRAY/BLACK (-)
@ BCM, C1 Pin 43, See NOTE
*1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN TAN (-)
@ BCM, C1, PN 4, See NOTE
*1
TACH Any wire NOT PNK @ any FUEL-NJECTOR
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ BCM, C2, PN 30, See NOTE
*1
FACTORY ALARM DSARM PURPLE (-)
@ BCM, C2 Pin 24, See NOTE
*1
ANT-THEFT
GM's PASSKEY 3 (PK3 on
Steel Shaft of gnition Key)
TRANSPONDER SYSTEM
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 the BCM (Body Control Module) is located to the LEFT of the STEERNG COLUMN, C1 is a
52-pin BLACK plug, C2 is a 52-pin BLACK plug, and C3 is a 18-pin BLACK plug. NOTE *2 the
DRVERS DOOR is a GRAY/BLACK (-) PN 26, the PASSENGER DOOR is a TAN/WHTE (-) PN
17, the DRVERS REAR DOOR is a LGHT BLUE/BLACK (-) PN 7 and the PASSENGER REAR
DOOR is a LGHT GREEN/BLACK (-) PN 5 all are at the BCM. When connecting to an ALARM
SYSTEM, use all 4 DOOR TRGGER wires and DODE SOLATE, to connect, .



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 20

Make: Model: Year:
Saturn S Series 2000-2002


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: GREEN (-) GNTON SWTCH HARNESS **
Accessory: BRWON GNTON SWTCH HARNESS
Brake Light: LT. BLUE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE OR ORANGE
AT GNTON MODULE TOP FRONT
CENTER OF ENGNE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: BLUE (-) AT HEADLGHT SWTCH ***
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * This vehicle is equipped with GM's PASSLOCK Anti-Theft system. See Note #113 -
General Motors PASSLOCK Bypass Diagram. ** This s The Key Sense Wire. t Needs To See
Ground During Remote Start To Prevent ""Service"" Light From Coming On.

Saturn S Series 2000-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
SEE NOTE ****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LT. BLUE (+) DRVER'S KCK PANEL *****
Power Unlock: WHTE (+) DRVER'S KCK PANEL *****
Trunk Release: GRAY OR BLACK (+) BEHND FUSE PANEL
Alarm nput Wire: SEE NOTE ****

NOTES: *** High Current Ground (-). Must Use A Relay To Provide Sufficent Ground. ****
Multiple Wires. Use Gray/Black (-) Found Near The Diagnostic Plug Harness Under Driver's
Dash For Driver's Door, Lt. Green/Black (-) Found n A Black 24-Pin Plug Behind The Fuse Box
n The Center Console For All Passenger Doors. Diode solate Each Wire With The Band Facing
Away From The Alarm/Remote Start Module. Use Only One Wire For Dome Light Supervision.
***** Positive Trigger Door Lock System. See nstallation Note #202 - Positive Pulse Door Lock
System.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 20

Make: Model: Year:
Saturn SC Coupe 1991-1994


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT D..S. MODULE *
Parking Lights: BROWN (+) HEADLGHT SWTCH OR STEERNG
COLUMN
Headlights: TAN (LOW) LGHT
GREEN
(HGH) AT HEADLGHT SWTCH (-)
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Distributorless gnition System (DS) Module Located On Top Rear Of Engine On
Driver Side.

Saturn SC Coupe 1991-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) BEHND FUSE BOX
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL **
Power Unlock: BLACK OR
BLACK/WHTE
DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: WHTE (-) BEHND FUSE BOX

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 20

Make: Model: Year:
Saturn SC Coupe 1995-1997


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH OR FUSE BLOCK
Headlights: D BLUE (LO) & PNK (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module Located Behind Driver Dash.

Saturn SC Coupe 1995-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: RED & RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE LOCATED N DRVER'S KCK PANEL ***
Power Unlock: WHTE LOCATED N DRVER'S KCK PANEL ***
Trunk Release: GRAY (+) AT OEM KEYLESS MODULE
Alarm nput Wire: WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **

NOTES: ** WHTE Wire Can Also Be Found n Passenger Side Rear Body Harness Wrapped
With Green Tape. *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 20

Make: Model: Year:
Saturn SC Coupe 2002


FUNCTON COLOR LOCATON
Start: Yellow gnition Switch Harness*
gnition #1: Pink gnition Switch Harness
gnition #2: White gnition Switch Harness**
gnition #3: N/A ****
Accessory: Orange gnition Switch Harness
Brake Light: Blue or White At Brake Switch
Tach Signal: WHT, ORG or PPL/White At Coil Pack On Engine
Parking Lights: Brown At Headlight Switch
Headlights: Yellow At Headlight Switch
Diesel Glow Plug: N/A
Clutch Bypass Wire: No Color Available Please call with information

NOTES: *Equipped with Passlock as standard equipment. Use Universal Alarm Bypass
Module. ** gnition 2 hot during run and crank ***f equipped with OEM alarm you will need a
Universal Alarm Bypass to temporarily bypass the OEM alarm during remote start. The OEM
alarm only fully disarms with the OEM remote. ****All remote starters except the 2xx22 have an
ignition 3 output - it is the white/black in the 'control harness.' This wire will be used to control the
bypass module(s).

Saturn SC Coupe 2002

FUNCTON COLOR LOCATON
Constant +12 Volts: Red gnition Switch Harness
OEM Alarm Disarm: N/A SEE NOTES! ***
Dome
Lights/Superv:
White Driver Kick Panel
OEM Horn: Black (-) At Steering Column Harness*
Power Lock: Light Blue Drivers Kick Panel*****
Power Unlock: White Drivers Kick Panel
Trunk Release: Gray or Black Trunk Release Switch
Alarm nput Wire: White Driver Kick Panel

NOTES: *The correct horn wire will measure 12 volts when you are not pressing the horn button.
While the horn button is pressed the correct wire will measure 0 volts. ***** See Note #202
Positive trigger door locks



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 20
Make: Model: Year:
Saturn Sedan 1998-1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH OR FUSE BLOCK
Headlights: D BLUE (LO) & PNK (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: This vehicle may require DesignTech's Universal Alarm Bypass Module if equipped with
OEM alarm. * Powertrain Control Module Located Behind Driver Dash.

Saturn Sedan 1998-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED & RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE LOCATED N DRVER'S KCK PANEL ***
Power Unlock: WHTE LOCATED N DRVER'S KCK PANEL ***
Trunk Release: GRAY (+) AT OEM KEYLESS MODULE
Alarm nput Wire: WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **

NOTES: ** WHTE Wire Can Also Be Found n Passenger Side Rear Body Harness Wrapped
With Green Tape. *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 20

SKY 2007

KE
Y
T-
HARNE
SS
MMOBLZER
N/A N/A
GM's PASS-KEY TRANSPONDER ANT-THEFT SYSTEM, Requires an Extra
Programmed gnition Key and 791 Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED/BLACK (+)
@ BCM, Connector C3, Pin D1
See NOTE *1
STARTER
YELLOW (Not for Remote
Starting) See NOTE *3
@ ECM, GRAY 56-Pin Plug, Pin
56 See NOTE *2
STARTER 2 N/A
GNTON 1 YELLOW (+)
@ GNTON HARNESS or @
BCM, Connector C4, Pin D3
See NOTE *1
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
@ GNTON HARNESS or @
BCM, Connector C4, Pin C8
See NOTE *1
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BROWN/WHTE (-)
@ HEADLGHT SWTCH or @
BCM, Connector C2, Pin 5 See
NOTE *1
PARKNG LGHTS ( + ) BROWN (+)
in DRVERS KCK PANEL or @
BCM, Connector C3, Pin A7
See NOTE *1
POWER LOCK GRAY (TYPE C) in DRVERS KCK PANEL
POWER UNLOCK TAN (TYPE C) in DRVERS KCK PANEL

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 20

DOOR TRGGER
GRAY/BLACK (-) (Drivers Door)
TAN/WHTE (-) (Passenger
Door) Use Both,
in EACH KCK PANEL or BCM,
C1, Pins 19 and 22 See NOTE
*1
DOMELGHT SUPERVSON GRAY (-)
@ BCM, Connector C3, Pin
A10, See NOTE *1
TRUNK RELEASE TAN (-)
@ HATCH RELEASE SWTCH
or @ BCM, Connector C2, Pin
10 See NOTE *1
SLDNG POWER DOOR N/A
HORN TAN (-)
@ HORN SWTCH or @ BCM,
Connector C2, Pin 14 See
NOTE *1
TACH
Any wire NOT PNK/BLACK or
PNK
@ Any FUEL-NJECTOR
WAT TO START LGHT N/A
BRAKE LGHT BLUE (+)
in PASSENGER KCK PANEL
or @ BCM, Connector C1, Pin
53 See NOTE *1
FACTORY ALARM DSARM
Disarms with Factory Remote
Only!!

ANT-THEFT
GM's PASS-KEY ANT-
THEFT SYSTEM
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 the BCM (Body Control Module) is attached to the FUSE/RELAY BOX located below the
GLOVE BOX. The BCM has 4 Connectors: C1, 72-Pin GRAY Plug, C2, 72-Pin GRAY Plug, C3, 41-
Pin RED Plug, C4, 68-Pin LGHT GRAY Plug. NOTE *2 the ECM (Engine Control Module) is located
in the DRVERS SDE REAR Corner of the Engine Compartment, NOTE *3 At the BCM, there is (2)
wires that perform as GNTON #2 and START, the WHTE and the WHTE/BLACK, located in C2,
Pins 56 and 62. These wires may need to be used to Crank the vehicle, no information at this time.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 20

Make: Model: Year:
Saturn SL Sedan 1991-1994


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT D..S. MODULE *
Parking Lights: BROWN (+) HEADLGHT SWTCH OR STEERNG
COLUMN
Headlights: TAN (LOW) LGHT
GREEN
(HGH) HEADLGHT SWTCH (-) NEGATVE
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Distributorless gnition System (DS) Module Located On Top Rear Of Engine On
Driver Side.

Saturn SL Sedan 1991-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) BEHND FUSE BOX
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL **
Power Unlock: BLACK OR
BLACK/WHTE
DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: WHTE (-) BEHND FUSE BOX

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 20

Make: Model: Year:
Saturn SL Sedan 1995-1997


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT CM CENTER FRONT OF ENGNE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH OR FUSE BLOCK
Headlights: D BLUE (LO) & PNK (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Use the White wire that is next to a Pink wire or use Violet/White in the same
connector.

Saturn SL Sedan 1995-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: RED & RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE LOCATED N DRVER'S KCK PANEL ***
Power Unlock: WHTE LOCATED N DRVER'S KCK PANEL ***
Trunk Release: GRAY (+) AT OEM KEYLESS MODULE
Alarm nput Wire: WHTE (-) AT FUSE BLOCK N DRVER KCK PANEL **

NOTES: * WHTE Wire Can Also Be Found n Passenger Side Rear Body Harness Wrapped
With Green Tape.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 20

Make: Model: Year:
Saturn SW Wagon 1993-1994


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT D..S. MODULE *
Parking Lights: BROWN (+) HEADLGHT SWTCH OR STEERNG
COLUMN
Headlights: TAN (LOW) LGHT
GREEN
(HGH) HEADLGHT SWTCH (-) NEGATVE
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Distributorless gnition System (DS) Module Located On Top Rear Of Engine On
Driver Side.

Saturn SW Wagon 1993-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) BEHND FUSE BOX
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OF AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL **
Power Unlock: BLACK OR
BLACK/WHTE
DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: WHTE (-) BEHND FUSE BOX

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 20

Make: Model: Year:
Saturn SW Wagon 1995-1997


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH OR FUSE BLOCK
Headlights: D BLUE (LO) & PNK (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module Located Behind Driver Dash.

Saturn SW Wagon 1995-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT FUSE BLOCK OR OEM KEYLESS
MODULE **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE LOCATED N DRVER'S KCK PANEL ***
Power Unlock: WHTE LOCATED N DRVER'S KCK PANEL ***
Trunk Release: GRAY (+) AT OEM KEYLESS MODULE
Alarm nput Wire: WHTE (-) AT FUSE BLOCK OR OEM KEYLESS
MODULE **

NOTES: ** OEM Keyless Module Located n Passenger Rear Quarterpanel. *** See Note #202 -
Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 20

Make: Model: Year:
Saturn Vue 2002-2005


FUNCTON COLOR LOCATON
Start: Yellow gnition Switch Harness
gnition #1: Pink gnition Switch Harness*
gnition #2: N/A
gnition #3: N/A
Accessory: Brown & Orange gnition Switch Harness**special note
Brake Light: Blue or White At Brake Switch
Tach Signal: White or Purple At Coil Pack
Parking Lights: Brown (+) At Headlight Switch
Headlights: No Color Available
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: *May be equipped with Passlock or PassKey transponder anti-theft system - Use a
universal alarm bypass module. **The ACC wire from the module must drive two external relays
to power up the Brown & Orange wire from the vehicle. The Brown & Orange wire MUST turn ON
and OFF at the exact same time or this will cause a Check Engine Light

Saturn Vue 2002-2005

FUNCTON COLOR LOCATON
Constant +12 Volts: Orange (+) gnition Switch Harness
OEM Alarm Disarm:
Dome
Lights/Superv:
Gry/Blk and Blk/white At Door Pins****
OEM Horn: Black (-) n steering Column Harness*****
Power Lock: Red/Black Driver Kick Panel******
Power Unlock: Orange/Black Drivers Kick Panel******
Trunk Release:
Alarm nput Wire: Gry/Blk and Blk/white At Door Pins****

NOTES: ****ndividual door circuits - Must diode isolate door pins or go directly to dome light.
The color at the dome light may vary. *****CAUTON - HARNESS MAY CONTAN AR-BAG
WRES. TO PREVENT NJURY OR VEHCLE DAMAGE, TEST ONLY WTH A DGTAL MULT-
METER SET FOR DC VOLTS! The correct horn wire will measure 12 volts when you are not
pressing the horn, zero volts with the horn sounding. ******n drivers kick panel where the rubber
boot comes from the door into the body of the vehicle. See Note #201 Negative Trigger Door
Locks



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Saturn - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 20
Make: Model: Year:
Saturn Wagon 1998-1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: L BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH OR FUSE BLOCK
Headlights: D BLUE (LO) & PNK (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: f equipped with OEM alarm this vehicle may require DesignTech's Universal Alarm
Bypass Module to temporarily disable the OEM alarm during remote start. * Powertrain Control
Module Located Behind Driver Dash.

Saturn Wagon 1998-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT FUSE BLOCK OR OEM KEYLESS
MODULE **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE LOCATED N DRVER'S KCK PANEL ***
Power Unlock: WHTE LOCATED N DRVER'S KCK PANEL ***
Trunk Release: GRAY (+) AT OEM KEYLESS MODULE
Alarm nput Wire: WHTE (-) AT FUSE BLOCK OR OEM KEYLESS
MODULE **

NOTES: ** OEM Keyless Module Located n Passenger Rear Quarterpanel. *** See Note #202 -
Positive Pulse Door Lock Diagram.

Вам также может понравиться