Академический Документы
Профессиональный Документы
Культура Документы
1. GEOMETRY CHECK Input Filename System carrier Format hm Size 7018 Date Uploaded 20/12/2012 Description
Features requiring special attention during modelling Feature Requirement Check PE TL Comment
Approved
Date
30/12/2011
Page 1 of 4
Requirement General appearance No free edges Check element normals Features captured as per Section 1 Material properties assigned No free 1D elements No duplicate elements Nodes on surface Nodes on feature lines Elements with properties Naming convention of collector Renumber elements Renumber nodes No rigid loops No double dependency Connectivity Debug run for Nastran (modal) For Solid Mesh (Hex/Tetra) Find faces, edges on faces 3 layers for thickness Min usage of penta and tetras For Tetra Mesh Shell coating Co-incident nodes Co-incident elements Algorithm used for creating tetras
Comment Must be good looking All elements must have same orientation
Check PE TL Y Y -
Comment
Dyna & Nastran Y Y Check with shaded view See cards As per client req. As per client req. As per client req. No 1Ds rigid loops No node should be double dependent No questionable connectivity in model
No T connection on these faces & enclosed volume When min size is not a constraint Only when transition or unavoidable area No free edges or cracks At matching face At matching face As per client req.
30/12/2011
Page 2 of 4
Element Quality Quality Measure 2D: Triangle Triangle Min Angle Triangle Max Angle Nominal Element Size Min Element Size Max Element Size 2D: Quadrilateral Triangle Min Angle Triangle Max Angle Quad Min Angle Quad Max Angle Warpage Skew Nominal Element Size Min Element Size Max Element Size %age Triangles 3D: Tetrahedral Triangle Min Angle Triangle Max Angle Tetrahedral Collapse Jacobian Nominal Element Size Min Element Size Max Element Size 3D: Hexahedral Triangle Min Angle Triangle Max Angle Quad Min Angle Quad Max Angle Aspect Ratio Skew Jacobian Nominal Element Size Criteria Preferred Min 20 120 8 145 # Failed Elements Preferred Min % Failed Elements Preferred Min
20 120 45 135 10 60
20 120 45 135 15 60
250
30/12/2011
Page 3 of 4
Date
Delivery Date
Delivered Via
Comment
Approved
Date
30/12/2011
Page 4 of 4