Академический Документы
Профессиональный Документы
Культура Документы
Topic- Preventive Maintenance PC1000 Occasionally an office will call in to have a preventive maintenance preformed on the PC-1000. This may be for the doctors peace of mind or a state requirement. The following steps should be followed and documented.
I.
II. III.
IV.
V.
VI.
VII.
Calibrate the PC-1000 a. Check no load voltage at the back of the KVP meter (91 VAC @80KVP +/- 1 VAC). In Addition, verify KVP needle moves smoothly. b. Check Line Voltage c. Set mA (6.0 Pan/10.0 Cephalometric +/_ . 10). d. Check pulse count (720 pulses +/- 10 or 12 seconds +/- 1 second). e. Visually inspect all board and wiring and listen for any unusual noises during exposure. Verify that unit is level and free of wobble. Check pan beam alignment. For exact beam alignment, remove film drum and align beam to center of film drum shaft. Once complete, move radiation strip to slotted plate, and adjust as needed. Tube head inspection a. Take an exposure at 80KVP and verify KVP meter deflection. Needle should deflect about 5 KVP. b. Remove tube head and inspect tube head knobs and slotted dogs. In addition, verify the tube head harness is free of damage. c. Verify tube moves freely in all directions. d. Remove rear tube head cover and verify the tube does not leak. Lift motor assembly a. Verify up/down switch works properly. b. Raise and lower the machine from top to bottom to verify proper operation of the lift motor. Any noise should be reported to Panoramic immediately. c. If a lift motor assembly was shipped, prior to your visit, install, and verify proper operations. Visual inspection of machine a. Floor mat wear (worn or pealing). b. Plastic covers (cracks or discoloration). c. Verify tube head decal on rear tube shell. Serial number should match machine serial number. d. Verify accessories (clear chin rest, black chin rest, and bite guides). Film and intensifying screens a. Visually inspect screens for cracks, wear, or stains. b. Inspect black cassette for rips and proper closure. c. Verify correct film and screen combination.
Form 20101
V.
VI.
VII.
Technician (Print)_________________________(Sign)___________________________
Form 20101