Академический Документы
Профессиональный Документы
Культура Документы
This document describes the interoperability and configuration of a Cisco 3640 voice gateway with a Nortel Meridian Opt11E PBX using E1-R2 CAS signaling. It includes the following sections: System Components Configuration Tasks Caveats
System Components
PBX Model PBX Release Telephony Signaling Voice Gateway Gateway Release VoX Protocol CallManager Nortel Meridian Opt11E Software Version Release 21 E1 R2 Cisco 3640 IOS Version 12.2(2)T1 H.323 Release 3.1
Configuration Tasks
See the following sections for configuration tasks for this feature: Set Up Nortel Meridian Option 11E PBX Sample Configuration Call Manager Configuration Cisco 3640 Gateway Configuration
Page 1
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
Set Up
This section includes the following information: Connectivity Diagrams Set Up Notes
Connectivity Diagrams
Basic Call Setup End-to-End Configuration
E1-R2 PBX1: Nortel Opt11E 3640 Phone A x3501 Cat 6K Ethernet Switch Cisco Call Manager Release 3.1
VoIP
PBX #1 Phone B x3502 Phone E x5000 Cisco 7960 IP phones Phone C x4001 Phone D x4002
Figure 1: Test Configuration Figure 1 represents the configuration used for testing: a Nortel Meridian Opt11E connected to a Cisco 3640 voice gateway via an E1 R2 connection.
Set Up Notes
Automatic number identification (ANI) feature is supported.
1.
Page 2
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
Page 3
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
4. 5. 6. 7.
Configure Trunk Configure Signaling Category Configure Multifrequency Compelled Signaling Table Configure Digital Station Phone Configure External Multi-frequency Sender/Receiver Board
Page 4
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
012 040
>
Page 5
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
SST DTD SCDT 2 DT NEDC FEDC CPDC DLTN HOLD SEIZ SVFL OPCB DDO DRNG CDR CCO NATL SSL CFWR IDOP MUS MR PANS RACD RUCS EQAR FRL FRL FRL FRL FRL FRL FRL FRL TTBL OHTD PLEV OPR PRDL DNSZ RCAL MCTS ALRM BTT ACKW NCNI CNIE CNIT CTAT ART OPDL PECL DCTI NADT SGRP REQ: >
FLH 510 GTO 896 GTI 896 SFB 3 TFD 0 5 0 NO NO NO ETH ETH NO NO 02 02 40 02 02 02 02 NO NO NO NO NO YES NO YES NO NO YES NO 0 NO 0 0 1 0 2 0 3 0 4 0 5 0 6 0 7 0 0 NO 2 NO NO 0 NO NO NO 30 NO 0 NO YES YES 0 0 NO 0 0 0 ****
Page 6
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
Configure Trunk
>LD 20 PT0000 MARP NOT ACTIVATED REQ: PRT TYPE: TNB TN 2 1 DATE PAGE DES TN 002 01 TYPE DID CUST 0 TRK DTI2 SICA 3 PDCA 1 PCML A NCOS 0 RTMB 102 1 NITE CLS UNR MFC CNA WTA LPR APN THFD BARD P10 MFL 4 MFPD NO TKID DTCR NO DATE 10 APR 1993 NACT **** >
Page 7
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
P RCOD (S) UNUSED P OPRS (R) UNUSED P NXFR (S) UNUSED P ESNW (S) UNUSED P CAS (S) UNUSED CLRF (R) UNUSED SOS (R) UNUSED OUTGOING CALLS E SEZ (S) 0101 SEZD (S) UNUSED SEZV (S) UNUSED SEZA (R) 1101 P WNKS (R) UNUSED P EOS (R) UNUSED CONN (S) 0001 E CONN (R) 0101 P OPRC (R) UNUSED P BURS (S) UNUSED P BURS (R) UNUSED C CLRB (R) 1101 P RCTL (R) UNUSED P NXFR (R) UNUSED P ESNW (R) UNUSED P CAS (R) UNUSED CLRF (S) UNUSED SOS (R) UNUSED UDATA: 067959 0 PDATA: 065844 44 DISK RECS AVAIL: 512 REQ > ****
Page 8
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
SCAT 5 SCNI 5 FAIL 15 TYPE ICOG MAXT TBNO EECD LVNO RECV R2MF ICT 2 1 1 2 1 2 3 5 6 7 8 9 10 11 12 13 NOPR PRIO NOPR OPER NOPR REST NOPR PRIO OPER NOPR NOPR NOPR 6 3 4 5 8 9
XMIT IDLE BUSY CONG VACC OUTT FAIL REQ > ****
Page 9
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
DGT6 6 DGT7 7 DGT8 8 DGT9 9 DGT0 10 ECNI 15 EODL 15 TYPE ICOG MAXT TBNO SET ATT TIE NTT EECD LVNO RECV R2MF OGT 2 2 1 1 6 6 2 2 2 3 4 5 6 8 9 IDLE BUSY CONG VACC IDLE OUTT FAIL 1 5 7
NO 0 UNR FBD WTA LPR MTD FND HTD ADD HFD MWD AAD IMD XHD IRD NID OLD VCE DRG1 POD DSX VMD CMSD CCSD SWD LND CNDA
Page 10
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
CFTD SFD MRD PDN DDV CNIA ICDD CDMD LLCN MCTA AUTU GPUD DPUD DNDA CFXA ARHD CLTD ASCD CPFA CPTA HSPD ABDD DELD CFHD FICD NAID UDI RCC HBTD AHD DDGA NAMA MIND PRSD NRWD NRCD NROD EXR0 USRD ULAD OCBD CPND_LANG ENG HUNT PLEV 02 AST IAPG 0 ITNA NO DGRP MLWU_LANG 0 DNDR 0 KEY 00 SCR 3501 MARP CPND CPND_LANG ROMAN NAME BIG BIRD XPLN 20 DISPLAY_FMT FIRST,LAST 01 02 03 CFW 12 3502 04 AO6 05 TRN 06 DSP 07 08 ADL 16 09 ADL 16 10 ADL 16 11 ADL 16 12 ADL 16 13 ADL 16 14 ADL 16 15 TRN DATE 13 APR 1993 NACT **** >
Page 11
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
DATE
3 APR 1993
Page 12
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
Page 13
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
Page 14
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
Page 15
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
ROM: System Bootstrap, Version 11.1(20)AA2, EARLY DEPLOYMENT RELEASE SOFTWARE (fc1) 3640 uptime is 2 minutes System returned to ROM by power-on System image file is "slot0:c3640-js-mz.122-2.T1.bin" cisco 3640 (R4700) processor (revision 0x00) with 59392K/6144K bytes of memory. Processor board ID 19594643 R4700 CPU at 100Mhz, Implementation 33, Rev 1.0 Channelized E1, Version 1.0. Bridging software. X.25 software, Version 3.0.0. SuperLAT software (copyright 1990 by Meridian Technology Corp). TN3270 Emulation software. Primary Rate ISDN software, Version 1.1. 2 Ethernet/IEEE 802.3 interface(s) 2 Channelized E1/PRI port(s) 2 Voice FXS interface(s) DRAM configuration is 64 bits wide with parity disabled. 125K bytes of non-volatile configuration memory. 8192K bytes of processor board System flash (Read/Write) 16384K bytes of processor board PCMCIA Slot0 flash (Read/Write) Configuration register is 0x1921 3640#sh diag Slot 0: Combo 2E, 2W Port adapter, 4 ports Port adapter is analyzed Port adapter insertion time unknown EEPROM contents at hardware discovery: Hardware revision 1.2 Board revision C0 Serial number 15878958 Part number 800-01171-05 Test history 0x0 RMA number 00-00-00 EEPROM format version 1 EEPROM contents (hex): 0x20: 01 1E 01 02 00 F2 4B 2E 50 04 93 05 00 00 00 00 0x30: 60 00 00 00 99 10 06 17 FF FF FF FF FF FF FF FF Slot 1: High Density Voice Port adapter Port adapter is analyzed Port adapter insertion time unknown EEPROM contents at hardware discovery: Hardware Revision : 1.0 Top Assy. Part Number : 800-03567-01 Board Revision : A0 Deviation Number : 0-0 Fab Version : 02 PCB Serial Number : JAB033906YA RMA Test History : 00 RMA Number : 0-0-0-0 RMA History : 00 EEPROM format version 4 EEPROM contents (hex): 0x00: 04 FF 40 00 CC 41 01 00 C0 46 03 0x10: 42 41 30 80 00 00 00 00 02 02 C1 0x20: 33 33 39 30 36 59 41 03 00 81 00 0x30: FF FF FF FF FF FF FF FF FF FF FF 0x40: FF FF FF FF FF FF FF FF FF FF FF
20 8B 00 FF FF
00 4A 00 FF FF
0D 41 00 FF FF
EF 42 04 FF FF
01 30 00 FF FF
Page 16
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
0x50: FF FF FF FF FF FF FF FF FF FF FF FF FF FF FF FF 0x60: FF FF FF FF FF FF FF FF FF FF FF FF FF FF FF FF 0x70: FF FF FF FF FF FF FF FF FF FF FF FF FF FF FF FF WIC Slot 0: E1 (2 Port) Multi-Flex Trunk WAN Daughter Card Hardware revision 1.0 Board revision B0 Serial number 18779447 Part number 800-04479-01 Test history 0x0 RMA number 00-00-00 Connector type PCI EEPROM format version 1 EEPROM contents (hex): 0x20: 01 23 01 00 01 1E 8D 37 50 11 7F 01 00 00 00 00 0x30: 58 00 00 00 00 02 25 00 FF FF FF FF FF FF FF FF HDV firmware: Compiled Fri 23-Mar-01 00:20 by miriyala HDV memory size 524280 heap free 197609 Slot 2: 4 PORT Voice PM for MARs Port adapter Port adapter is analyzed Port adapter insertion time unknown EEPROM contents at hardware discovery: Hardware revision 1.0 Board revision B0 Serial number 7968450 Part number 800-02491-01 Test history 0x0 RMA number 00-00-00 EEPROM format version 1 EEPROM contents (hex): 0x20: 01 65 01 00 00 79 96 C2 50 09 BB 01 00 00 00 00 0x30: 58 00 00 00 98 04 01 17 FF FF FF FF FF FF FF FF WIC Slot 0: FXS Voice daughter card (2 port) Hardware revision 1.1 Board revision B0 Serial number 24298176 Part number 800-02493-02 Test history 0x0 RMA number 00-00-00 Connector type Wan Module EEPROM format version 1 EEPROM contents (hex): 0x20: 01 0E 01 01 01 72 C2 C0 50 09 BD 02 00 00 00 00 0x30: 58 00 00 00 01 02 05 01 FF FF FF FF FF FF FF FF
Page 17
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
voice-card 1 ! ip subnet-zero ! ! no ip domain-lookup ! no ip dhcp-client network-discovery isdn switch-type primary-dms100 isdn voice-call-failure 0 call rsvp-sync voice rtp send-recv ! voice class codec 1 codec preference 1 g729r8 codec preference 2 g711ulaw codec preference 3 g711alaw ! ! ! ! ! ! ! controller E1 1/0 shutdown ! controller E1 1/1 framing NO-CRC4 ds0-group 1 timeslots 1-15,17-31 type r2-analog r2-compelled ani ! ! ! interface Ethernet0/0 ip address 10.18.1.2 255.255.255.0 no ip mroute-cache full-duplex no cdp enable ! interface Ethernet0/1 ip address 10.1.1.129 255.255.255.0 no ip mroute-cache half-duplex no cdp enable ! ip classless no ip http server ! no cdp run ! ! ! snmp-server manager ! voice-port 1/1:1 ! voice-port 2/0/0 ! voice-port 2/0/1 ! dial-peer cor custom ! ! ! dial-peer voice 3 voip destination-pattern 4... voice-class codec 1 session target ipv4:10.1.1.2
Page 18
Cisco 3640 Gateway-PBX Interoperability: Nortel Meridian Opt11E with E1-R2 CAS Signaling
dtmf-relay h245-alphanumeric ip qos dscp cs5 media no vad ! dial-peer voice 4 pots destination-pattern 5000 port 2/0/0 ! dial-peer voice 6 pots destination-pattern 35.. direct-inward-dial port 1/1:1 prefix 35 ! ! line con 0 exec-timeout 0 0 privilege level 15 speed 115200 line aux 0 line vty 0 4 ! ! end
Caveats
When calling from a Cisco 7960 IP phone to Nortel digital phone the Calling/Called Number is displayed on both phones after the call is answered. When calling from a Nortel digital phone to a Cisco 7960 IP phone, the IP phone displays calling number after the call is answered. Nortel phone however does not get updated when the call is answered because connected number presentation is not a supported feature for E1-R2 signaling protocol. It displays the numbers being dialed instead. An example would be Access Code + extension number.
Page 19