Академический Документы
Профессиональный Документы
Культура Документы
Revision Records
Date Revised version Description Author
2005-02-26
Page 2 of 8
Table of Contents
Chapter 1 SS42AIU Board Software.............................................................................................5 1.1 Application Introduction to 4.07.01.02(0213) Version of SS42AIU Board Software.............5 Chapter 2 SS42ET1 Board Software.............................................................................................5 2.1 Application Introduction to V1.11 Version of SS42ET1 Board Software..............................5 2.2 Application Introduction to V1.22 version of SS42ET1 Board Software...............................6 2.3 Application Introduction to V1.33 Version of SS42ET1 Board Software..............................7 Chapter 3 Precautions for Metro Deployment.............................................................................7 3.1 SS42AIU Board Software Deployment Description ............................................................7 3.2 SS42ET1 Board Software Deployment Description............................................................8
2005-02-26
Page 3 of 8
Keyword: Application Introduction to Metro1000 Board Version Summary: -3001. support (only support) CBR service; 2. support VP-Ring function (1+1 single-ended protection switching function) 3. support PVP/PVC connection management function: connect ID range (1-1024), Vpi range (1--127), Vci range (32--127); support point-to-point (p2p) bidirectional connection, support unidirectional connection of multicast (p2mproot, p2mpleaf); and support switching function of connection Vpi/Vci. Abbreviation list: None. Reference list: None.
2005-02-26
Page 4 of 8
3 4
Host software: 4.02.05.04 (0421), temporary filing NM software: NES 4.4.0.7 (temporary filing), RMS4.7.3.2 (not issued) Application principle: Before filing, the formal version is used for point-to-point Ethernet transparent transmission service deployment . Functions: 1. MP setting and management function: support at most 16 pieces of MP setting (binding virtual path). Certain (1 to 48) 2M (VC12) can be defined as one MP port. Also support port convergence such as 10M->1 to 5 pieces of 2M. 2. Static route defining function: support the setting and query of unidirectional and bidirectional MACport-MPport port route. 3. Set up Ethernet interface with enabling and working mode function. 4. support Ethernet service performance function. Version defects:
Serial No. 1 Defect Description of Known Version Because of the mismatch between 4.02.05.04 (0421) host software and ET1 board software, configuration data sometimes affects the correctness of route data in sending configuration. When sending command "cfginit<sysall>", Ethernet service is affected immediately and the service is interrupted and recovers only at the moment that the new service sent by "cfg-checkout" goes into effect . When switching to the standby path in PP ring, there is no PS switchover alarm in 2M path on ET1 board. Corresponding Precaution Route index number is set in ascending order from 100.
understand
understand
Before filing, the formal version is used for VLAN function deployment. Version defect:
Defect Description of Known Version Because of the mismatch between 4.02.05.04(0421) host software and ET1 board software, the configuration data sometimes affects the correctness of route data in sending configuration. Test the data packet with frame length of 64 to 128 byte and low throughput Corresponding Precaution Route index number is set in the ascending order from 100
understand
service type, it is recommended that the traffic flow of each ATM connected to PCM be more that 10Mbit/s, that is 23585 Cell/s, and CDVT value be 10000.
2005-02-26
Page 8 of 8