Академический Документы
Профессиональный Документы
Культура Документы
The primary function of the bias circuit is to A. B. C. hold the circuit stable at VCC hold the circuit stable at vin ensure proper gain is achieved hold the circuit stable at the designed Q-point D
D.
A JFET A. B. C. is a current-controlled device has a low input resistance is a voltage-controlled device is always forward-biased C
D.
C.
The capacitor that produces an ac ground is called a(n) A. B. coupling capacitor dc open
C.
D.
The formula used to calculate the approximate ac resistance of the base-emitter diode (re) is A.
B.
re
25 mV IC
C.
6.
B.
Av = IC RC
C.
D.
Answer & Explanation
Answer: Option C Explanation: No answer description available for this question. Let us discuss. View Answer Workspace Report Discuss in Forum
7.
In a class B push-pull amplifier, the transistors are biased slightly above cutoff to avoid A. B. C. D. crossover distortion unusually high efficiency negative feedback a low input impedance
Answer: Option A Explanation: No answer description available for this question. Let us discuss. View Answer Workspace Report Discuss in Forum 8.
The depletion-mode MOSFET A. B. C. D. can operate with only positive gate voltages can operate with only negative gate voltages cannot operate in the ohmic region can operate with positive as well as negative gate voltages
Answer: Option D Explanation: No answer description available for this question. Let us discuss. View Answer Workspace Report Discuss in Forum 9.
Three different points are shown on a dc load line. The upper point represents the A. B. C. D. minimum current gain quiescent point saturation point cutoff point
Answer: Option C Explanation: No answer description available for this question. Let us discuss. View Answer Workspace Report Discuss in Forum 10. Which of the following conditions are needed to properly bias an npn transistor amplifier? A. Forward bias the base/emitter junction and reverse bias the base/collector junction. Forward bias the collector/base junction and reverse bias the emitter/base junction. Apply a positive voltage on the n-type material and a negative voltage on theptype material. Apply a large voltage on the base.
B.
C.
D.
Answer: Option A Explanation: No answer description available for this question. Let us discuss. View Answer Workspace Report Discuss in Forum 11. Often a common-collector will be the last stage before the load; the main function of this stage is to A. B. C. D. provide voltage gain buffer the voltage amplifiers from the low-resistance load provide phase inversion provide a high-frequency path to improve the frequency response
Answer: Option B Explanation: No answer description available for this question. Let us discuss. View Answer Workspace Report Discuss in Forum
12. In order for feedback oscillators to have any practical value, the gain has to be A. B. C. D. <1 self-adjusting stabilized nonlinear
Answer: Option B Explanation: No answer description available for this question. Let us discuss. View Answer Workspace Report Discuss in Forum 13. To get a negative gate-source voltage in a self-biased JFET circuit, you must use a A. B. C. D. voltage divider source resistor ground negative gate supply voltage