Вы находитесь на странице: 1из 2

->

Technical Data Sheet

Procontrol P13 Processing Modules Programmable Processor 70PR05B-ES


-> ->
Processing of binary and analog signals for binary control, analog control and computational tasks according to instructions in the (E)EPROM. Parameters can be changed on line without modification to the program. Can be applied as a single module or with a partner module in redundant mode. Two processors can be operated as active/standby. Should the active fail, the standby processor will take over the processing tasks without interruption. Replace the older processors 70PR02 and 70PR03. Program conversion with WINtools.

-> ->

-> ->

-> ->
Technical Data Identification Number: Type: Technical Description: HESG332204R0001 70PR05B-ES 1 functional unit 1 socket on the front for connecting simulation and programming tools. WINtools 1 code switch on the front for setting the module address combination functions specified in the programming language BBC-PROCONTROL P10

-> ->

(E)EPROM for H32K instruction lines for definition of the processing of the selected signals RAM for storage of 256 parameter values with values retained in the event of voltage failure 1 switchjack for testing redundance switchover 1 switchjack for read only access to service tools via the local bus 1 switchjack for clearing simulation memory 1 switchjack for switchover to passive operating mode

->

Contact us

Power Systems Dept. PSPS Bruggerstrasse 72 CH-5400 Baden, Switzerland Phone: +41 (0)844 845 845 (customer contact center 24hours/365days) Phone: +41 (0)58 585 88 80 (during office hours) Email: plantcontrol.support@ch.abb.com

ABB India Ltd Dept. PS-PG Plot Nos 5 & 6 2nd Phase Bangalore, Peenya Industrial Estate Bangalore 560058 Karnataka, India Phone: +91 80 2294 9628 Fax: +91 80 2839 6121 Email: psp-pgs@in.abb.com

ABB Inc. Power Generation 29801 Euclid Avenue 44092-1832, Wickliffe, Ohio, USA Phone: +1 440 585 3087 Email: powergeneration@us.abb.com

www.abb.com/powergeneration

Notice The information in this document is subject to change without notice and should not be construed as a commitment by ABB. ABB assumes no responsibility for any errors that may appear in this document. In no event shall ABB be liable for direct, indirect, special, incidental or consequential damages of any nature or kind arising from the use of this document, nor shall ABB be liable for incidental or consequential damages arising from ung -> use of any software or hardware described in this document. This document and parts thereof must not be reproduced or copied without written permission from ABB, and the contents thereof must not be imparted to a third party nor used for any unauthorized purpose. The software or hardware described in this document is furnished under a license and may be used, copied, or disclosed only in accordance with the terms of such license. This product meets the requirements specified in EMC Directive 89/336/ EEC and in Low Voltage Directive 72/2

2VAA000760A | Printed in Switzerland, 2011

ang -> ABB Switzerland Ltd

Copyright 2011 ABB. All rights reserved. Specifications subject to change without notice.

Вам также может понравиться