Академический Документы
Профессиональный Документы
Культура Документы
SERVICE MANUAL
CHASSIS NO. : CL-62
MODEL: Photon19vision
CAUTION
BEFORE SERVICING THE UNIT,
READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
LIGHT VIEW
AUTO
SOURCE
MENU
SELECT
CONTENTS
SPECIFICATIONS ................................................... 2
PRECAUTIONS ....................................................... 4
TIMING CHART ....................................................... 5
OPERATING INSTRUCTIONS ................................ 6
WIRING DIAGRAM ................................................. 8
BLOCK DIAGRAM ................................................... 9
SPECIFICATIONS
1. LCD CHARACTERISTICS
Type
: TFT Color LCD Module
Size
: 19inch(48cm)diagonal
Pixel Pitch
: 0.294(H) x 0.294(V)
Color Depth
: 8-bit, 16,777,216 colors
Electrical Interface
: LVDS
Surface Treatment
: Anti-Glare, Hard Coating(3H)
Operating Mode
: Normally Black
Backlight Unit
: 4-CCFL (Cold Cathode
Fluorescent Lamp)
2. OPTICAL CHARACTERISTICS
2-1. Viewing Angle by Contrast Ratio
Left
: - 85 min., - 88(Typ)
Right : +85 min., +88(Typ)
Top
: +85 min., +88(Typ)
Bottom : - 85 min., - 88(Typ)
5. POWER SUPPLY
5-1. Power Adaptor(Built-in Power)
Input
: AC 100~240V, 50/60Hz , 1.0A
5-2. Power Consumption
MODE
10
2-2. Luminance
: 185(min), 250(Typ)
: 250(min), 400(Typ)
POWER ON (NORMAL)
ON/ON
ACTIVE
less than 45 W
GREEN
STAND-BY
OFF/ON
OFF
less than 1 W
AMBER
SUSPEND
ON/OFF
OFF
less than 1 W
AMBER
DPM OFF
OFF/OFF
OFF
less than 1 W
AMBER
less than 1 W
OFF
6. ENVIRONMENT
6-1. Operating Temperature: 10C~35C
6-2. Relative Humidity
: 10%~80%
6-3. MTBF
: 50,000 Hours
Lamp Life
: 40,000 Hours(Min)
7. DIMENSIONS (with TILT/SWIVEL)
Width
Depth
Height
: 413 mm (16.26'')
: 228 mm (8.98'')
: 435mm (17.13'')
Net. Weight
Gross Weight
: R, G, B Analog
: 0~0.7 V
: 0 Vp-p
: 0.35 Vp-p
: 0.7 Vp-p
: 75
9. USB
Upstream : 1 port, Downstream : 2 port
Speed : Full-12Mbps, Low-1.5Mbps
: 30 ~ 83kHz
: 30 ~ 71kHz
: 56 ~ 75Hz
: 1280 x 1024@75Hz
: 1280 x 1024@60Hz
-2-
1
9
17
8
16
24
Pin
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
Signal (DVI-D)
T. M. D. S. Data2T. M. D. S. Data2+
T. M. D. S. Data2/4 Shield
T. M. D. S. Data4T. M. D. S. Data4+
DDC Clock
DDC Data
Analog Vertical Sync.
T. M. D. S. Data1T. M. D. S. Data1+
T. M. D. S. Data1/3 Shield
T. M. D. S. Data3T. M. D. S. Data3+
+5V Power
Ground (return for +5V,
Pin
16
17
18
19
20
21
22
23
24
Signal (DVI-D)
Hot Plug Detect
T. M. D. S. Data0T. M. D. S. Data0+
T. M. D. S. Data0/5 Shield
T. M. D. S. Data5T. M. D. S. Data5+
T. M. D. S. Clock Shield
T. M. D. S. Clock+
T. M. D. S. Clock-
-3-
PRECAUTION
WARNING FOR THE SAFETY-RELATED COMPONENT.
WARNING
CAUTION
Please use only a plastic screwdriver to protect yourself
from shock hazard during service operation.
-4-
TIMING CHART
VIDEO
C
D
SYNC
<< Dot Clock (MHz), Horizontal Frequency (kHz), Vertical Frequency (Hz), Horizontal etc... (s), Vertical etc... (ms) >>
Mode
1
2
3
4
5
6
7
8
9
10
11
12
13
H/V
Sort
Sync
Polarity
V
H
+/
+/
V
H
+/
+/
+/
+/
Dot
Clock
25.175
28.321
25.175
31.5
40.0
49.5
57.283
65.0
78.75
100.0
92.978
108.0
135.0
Frequency
Front Porch
(C)
Sync Duration
(D)
Back Porch
(F)
31.469
800
640
16
96
48
70.8Hz
449
350
37
60
31.468
900
720
18
108
54
70.09
31.469
449
840
400
640
12
16
2
96
35
48
59.94
525
480
10
33
37.5
840
640
16
64
120
75
500
480
16
37.879
1056
800
40
128
88
60.317
628
600
23
46.875
1056
800
16
80
160
75.0
625
600
21
49.725
1152
832
32
64
224
74.55
667
624
39
48.363
1344
1024
24
136
160
60.0
806
768
29
60.123
1312
1024
16
96
176
75.029
68.681
800
1456
768
1152
1
32
3
128
28
144
75.062
915
870
39
61.805
1504
1152
18
134
200
65.96
937
900
31
63.981
1688
1280
48
112
248
60.02
1066
1024
38
79.976
1688
1280
16
144
248
75.035
1066
1024
38
-5-
Resolution
640x350
70Hz
720x400
70Hz
640x480
60Hz
640x480
75Hz
800x600
60Hz
800x600
75Hz
832x624
75Hz
1024x768
60Hz
1024x768
75Hz
1152x870
75Hz
1152x900
65Hz
1280x1024
60Hz
1280x1024
75Hz
OPERATING INSTRUCTIONS
FRONT VIEW
REAR VIEW
D-Sub Signal
Connect
DVI
Connect
Power
Connect
USB Port
LightView
1. Power Button
Use this button to turn the display on or off.
Power (DPMS) Indicator
This Indicator lights up green when the display operates
normally. If the display is in DPM (Energy Saving) mode,
this indicator color changes to amber.
2. MENU Button
Use this button to enter or exit the On Screen Display.
3.
Button
100
100
4. AUTO/SELECT Button
Use this button to enter a selection in the On Screen
Display.
When adjusting your display settings,
always press the AUTO/SELECT button
before entering the On Screen
Display(OSD). This will automatically
adjust your display image to the ideal settings for the current
screen resolution size (display mode).
The best display mode is 1280x1024.
5. SOURCE
Use this button to make Dsub or DVI connector active. This
feature is used when two computers are connected to the
display. The default setting is Dsub.
-6-
USB connection
1. Connect the upstream port of the Display to the downstream port of the USB compliant PC or another hub using the
USB cable. (Computer must have a USB port)
2. Connect the USB compliant peripherals to the downstream ports of the monitor.
NOTE
To activate the USB hub function, the monitor must be connected to a USB compliant PC(OS) or another hub with the USB
cable(enclosed).
When connecting the USB cable, check that the shape of the connector at the cable side matches the shape at the connecting
side.
Even if the monitor is in a power saving mode, USB compliant devices will function when they are connected the USB ports(both
the upstream and downstream) of the monitor.
-7-
WIRING DIAGRAM
6631T11012W
Power Board
Connector Assy P/N:
6631T20020Q
6631T20024B
MS
T9
15
J702
J706
Main Board
J705
J1
Control Board
-8-
AC I nput
12V
-9-
LIPS
5V
2.5V
Diode
KDS184
3.3V
Reg.
3.3V
3.3V
5V
D-SUB
3.3V
2.5V
5V
R,G,B, H/ V Sync
Digital Signal
(ADC/LVDS/SCALER
/INPUT SWITCHING
/TMDS )
MST9131B
including
R,G,B
differential
L V DS
(L ow Vo lt age
Dif f e r en t i al
Si gnal ing)
LCD Module
DVI-D
MTV312
Micom
USB
HUB
Bus-power USB
U/S
D/S
D/S
BLOCK DIAGRAM
- 10 -
12V
50 ~ 60Hz
EMI
COMPONENTS
INPUT RECTIFIER
AND FILTER
HVDC
ENERGY
TRANSFER
100KHz
OUTPUT RECTIFIER
AND FILTER
5V
GND
LINE
100 ~ 240V
PWM
CONTROL
CIRCUIT
PHOTOCOUPLER
ISOLATION
PRIMARY
SIGNAL
COLLECTI
ON
SECONDARY
Operation description_LIPS
1. EMI components.
This part contains of EMI components to comply with global marketing EMI standards like FCC, VCCI CISPR, the
circuit included a line-filter, across line capacitor and of course the primary protection fuse.
2. Input rectifier and filter.
This part function is for transfer the input AC voltage to a DC voltage through a bridge rectifier and a bulk capacitor.
3. Energy Transfer.
This part function is transfer the primary energy to secondary through a power transformer.
4. Output rectifier and filter.
This part function is to make a pulse width modulation control and to provide the driver signal to power switch, to
adjust the duty cycle during different AC input and output loading condition to achive the dc output stablize, and also
the over power protection is also monitor by this part.
5. Photo-Coupler isolation.
This part function is to feed back the dc output changing status through a photo transistor to primary controller to
achieve the stabilized dc output voltage.
6. Signal collection.
This part function is to collect the any change from the dc output and feed back to the primary through photo
transistor.
- 11 -
ADJUSTMENT
Windows EDID V1.0 User Manual
- 12 -
SERVICE OSD
1) Turn off the power switch at the front side of the display.
2) Wait for about 3 seconds and press MENU, POWER switch.
3) The SVC OSD menu contains additional menus that the User OSD menu as described below.
a) MODULE : To select applied module.
b) NVRAM INIT : EEPROM initialize(24C08)
c) ADC OFFSET : The lowest value of input leves sets to digitally 0(zero).
d) ADC GAIN : The highest value of input levels sets to digitally 255.
e) ADC CAL : W/B balance sets the gain and offset value.
f) ELAPSED CLEAR : To initialize using time.
A
9
IBM
Compatible PC
Video Signal
Generator
15
10
5
11
6
1
6
1
C
13
se
PARALLEL PORT
2C
tu
23
No
RS
5V
OFF
14
ON
LL
E
RA
PA
5V
ER
220
PO
W
VG
ST
MO
NI
TO
V-S
YN
C
Control Line
25
E
4.7K
OFF
74LS06
E ST Switch
- 13 -
4.7K
4.7K
5V
74LS06
TROUBLESHOOTING GUIDE
1. NO POWER
NO POWER
(POWER INDICATOR OFF)
CHECK J705
VOLTAGE
PIN5, PIN6 (5V)?
NO
CHECK POWER
BOARD, AND FIND
OUT A SHORT POINT
AS OPENING
EACH POWER LINE
YES
CHECK
U501 PIN 8 Voltage
(5V) ?
NO
YES
IS U201
PIN114 (3.3V)
VOLTAGE ?
NO
YES
NO
YES
CHECK U201
- 14 -
CHECK X-TAL
NO RASTER
(OSD IS NOT DISPLAYED)
J705
PIN5, PIN6
5V?
NO
CHECK LIPS
YES
J705 PIN 9
5V?
NO
YES
J705 PIN10
5V?
NO
1. CONFIRM BRIGHTNESS
OSD CONTRL STATE.
2. CHECK MICOM DIM-ADJ
PORT
YES
CHECK
PULSE AS
CONTACTING SCOPE
PROBE TO CAUTION LABEL.
(CONTACT PROBE TO
CAUTION LABEL.
CAN YOU SEE PULSE
AT YOUR
SCOPE?
NO
YES
- 15 -
LIPS
U201
POWER PIN 8, 114
(3.3V)?
NO
CHECK U801
YES
U201
PIN122, 123
OSCILLATE AS
12MHZ?
NO
YES
U501
PIN43 IS 64KHz H-SYNC?
PIN44 IS 60Hz V-SYNC?
IS PULSE APPEARED
AT SIGNAL PINS?
AT MODE 12?
NO
YES
TROUBLE IN CABLE
OR LCD MODULE
- 16 -
4. TROUBLE IN DPM
TROUBLE IN DPM
CHECK
R756, R760
(SYNC) ?
NO
CHECK PC
PC IS NOT GOING
INTO DPM OFF MODE
NO
YES
CHECK
U501 PIN 43.44
SYNC PULSE?
YES
TROUBLE IN U501
- 17 -
- 18 -
10
25
11
26
EXPLODED VIEW
27
13
14
12
15
20
22
23
18
19
17
24
21
16
Part No.
3091TKL112A
6304FLP075A
6304FLP129A
6304FLP134A
3809TKL051M
BACK COVER ASSEMBLY, L1912 TKL053 LUPOY GN5008HF DARK BLUE LACIE
3043TKK105F
6871TST415A
4951TKS126G
6871TPT271V
6871TPT271E
PWB(PCB) ASSEMBLY,POWER, 19" M-CHASSIS POWER TOTAL LIEN CHANG " INTEGRATED LIPS" USED 7812
3313TL9025A
6631T11012W
10
6871TKT294A
11
4951TKS118D
12
3550TKK220E
13
3550TKK218F
14
3550TKK222G
15
6871TUT015A
16
3550TKK223F
17
3550TKK219F
18
3550TKK221E
19
3550TKK217F
20
3550TKK216F
21
4950TKK346A
22
3550TKK224C
23
4970TKK009A
24
4950TKK344A
6850TD9004D
Description
25
or 6850TD9004J
26
6866TDV004C
27
6866TDU002D
332-113E
- 19 -
PART NO.
MAIN BOARD
CAPACITORS
C204
C205
C206
C207
C208
C209
C210
C211
C213
C214
C215
C216
C217
C218
C219
C220
C221
C222
C223
C224
C225
C226
C227
C230
C231
C232
C233
C240
C251
C501
C502
C503
C504
C506
C507
C508
C701
C703
C707
C708
C709
C710
C711
C712
C713
C714
C717
C718
C719
C720
C721
C722
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CC101CK41A
0CC101CK41A
0CK104CK56A
0CH8106F611
0CC030CK01A
0CC180CK41A
0CK104CK56A
0CK105CD56A
0CK104CK56A
0CC680CK41A
0CK103CK51A
0CK103CK51A
0CK103CK51A
0CK103CK51A
0CK104CK56A
0CC101CK41A
0CC101CK41A
0CC101CK41A
0CC101CK41A
0CC680CK41A
0CC101CK41A
0CK103CK51A
0CK103CK51A
C723
C724
C725
C726
C727
C728
C732
C733
C734
C735
C737
C738
C739
C740
C741
C742
C743
C760
C801
C803
C804
C805
C806
C807
C808
C809
C810
C812
C814
C815
C816
C817
C818
PART NO.
0CK103CK51A
0CK103CK51A
0CK103CK51A
0CK103CK51A
0CK105CD56A
0CK103CK51A
0CK103CK51A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CK104CK56A
0CE107EF610
0CK103CK51A
0CE107EF610
0CK104CK56A
0CK105CD56A
0CK103CK51A
0CE107EF610
0CK104CK56A
0CK103CK51A
0CK104CK56A
0CE107EF610
0CE107EF610
0CK104CK56A
0CK103CK51A
0CK104CK56A
0CC102CK41A
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DD184009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
0DS226009AA
DIODEs
D701
D702
D706
D708
D709
D710
D711
D712
D713
D714
D715
D719
D720
D721
D722
D723
D724
D725
- 20 -
PART NO.
D804
D805
ZD701
ZD702
ZD703
ZD704
ZD705
ZD706
ZD709
ZD711
ZD712
0DD184009AA
0DD184009AA
0DZ560009GB
0DZ560009GB
0DZ560009GB
0DZ560009GB
0DZ560009GB
0DZ560009GB
0DZ560009GB
0DZ560009GB
0DZ560009GB
U201
U501
U502
U703
U801
U802
0IPRPM3011B
0IZZTSZ330A
0ISG240860B
0IMMRSG036A
0IPMGKE011A
0TFVI80036A
ICs
TRANSISTOR
Q502
Q503
Q504
Q505
Q703
Q704
Q706
Q707
0IKE704200H
0TR390409AE
0TR390409AE
0TR390409AE
0TR390609FA
0TR390609FA
0TR390409AE
0TR390409AE
RESISTORs
R201
R202
R203
R207
R208
R209
R210
R216
R217
R220
R240
R501
R506
R508
R512
R513
R514
R515
R516
R518
R519
R520
R521
R522
R523
R524
R525
R526
0RJ0682D677
0RJ0682D677
0RJ0682D677
0RJ3900D677
0RJ0682D677
0RJ0682D677
0RJ0682D677
0RJ0000D677
0RJ0000D677
0RJ4701D677
0RJ1001D677
0RJ4701D677
0RJ4701D677
0RJ4701D677
0RJ0332D677
0RJ0332D677
0RJ4701D677
0RJ4701D677
0RJ4701D677
0RJ4701D677
0RJ1000D677
0RJ4701D677
0RJ4701D677
0RJ4701D677
0RJ4701D677
0RJ1000D677
0RJ1000D677
0RJ1000D677
- 21 -
PART NO.
0RJ1000D677
0RJ1000D677
0RJ1000D677
0RJ1002D677
0RJ1000D677
0RJ1000D677
0RJ0000D677
0RJ3301D677
0RJ3301D677
0RJ1000D677
0RJ1000D677
0RJ4701D677
0RJ4701D677
0RJ4700D677
0RJ0000D677
0RJ4700D677
0RJ0332D677
0RJ0332D677
0RJ1000D677
0RJ4700D677
0RJ1000D677
0RJ4702D677
0RJ4701D677
0RJ1000D677
0RJ1000D677
0RJ1000D677
0RJ0752D677
0RJ2001D677
0RJ0752D677
0RJ2001D677
0RJ0752D677
0RJ4700D677
0RJ1001D677
0RJ0102D677
0RJ0102D677
0RJ4701D677
0RJ4701D677
0RJ0000D677
0RJ1000D677
0RJ0332D677
0RJ0332D677
0RJ1002D677
0RJ1002D677
0RJ0222D677
0RJ0222D677
0RJ1000D677
0RJ4700D677
0RJ0000D677
0RJ4701D677
0RJ4701D677
0RJ4701D677
0RJ4701D677
0RJ1001D677
0RJ4701D677
0RJ1001D677
0RJ4701D677
0RJ0000D677
0RJ1002D677
0RJ1002D677
0RJ0332D677
0RJ0332D677
0RJ0000D677
PART NO.
0RJ0122D677
0RJ0122D677
0RJ0122D677
0RJ0122D677
0RJ0122D677
0RJ0122D677
0RJ0682D677
0RJ1000D677
0RJ0000D677
0RJ0000D677
0RJ0000D677
0RJ2202D677
0RJ5600D677
0RJ0000D677
0RJ0000D677
0RJ0000D677
6212AA2004A
OTHERs
X501
CONTROL BOARD
LED1
R1
R2
R3
R4
R5
R6
R7
R8
SW1
SW2
SW3
SW4
SW5
SW6
SW7
SW8
0DLLT0208AA
0RJ4701D677
0RJ4701D677
0RJ8200D677
0RJ8200D677
0RJ1501D677
0RJ1501D677
0RJ2201D677
0RJ2201D677
140-058E
140-058E
140-058E
140-058E
140-058E
140-058E
140-058E
140-058E
USB BOARD
C1
C18
C2
C23
C24
C25
C27
C28
C31
C32
C37
C38
C39
C6
C8
C9
D1
L13
L14
0CH8107F611
0CK104CK56A
0CK103CK51A
0CH8107F611
0CC470CK41A
0CC470CK41A
0CH8107F611
0CK103CK51A
0CK104CK56A
0CK104CK56A
0CH8107F611
0CC470CK41A
0CC470CK41A
0CH3105F946
0CC150CK41A
0CC150CK41A
0DS181009AA
6210TCE001B
6210TCE001P
- 22 -
PART NO.
6210TCE001P
6210TCE001P
6210TCE001P
6210TCE001B
6210TCE001P
6210TCE001P
6210TCE001P
6210TCE001P
0RJ0000D677
0RJ1502D677
0RJ1001D677
0RJ0222D677
0RJ0222D677
0RJ1502D677
0RJ1502D677
0RJ0000D677
0RJ1002D677
0RJ0222D677
0RJ0222D677
0RJ1502D677
0RJ1502D677
0RJ0222D677
0RJ0222D677
0RJ1501D677
0RJ1501D677
0RJ1002D677
0RJ1002D677
0RJ1501D677
0IRH033200A
0IPRPTI007A
0ITI204200B
6202TST001C
0DZ560009DA
0DZ560009DA
0DZ560009DA
0DZ560009DA
0DZ560009DA
0DZ560009DA
SCHEMATIC DIAGRAM
1. MST9131B
. 11. 18
- 23 -
2. MICOM
. 11. 18
- 24 -
3. POWER
. 11. 18
- 25 -
- 26 -
P/NO : 3828TSO058K
Apr. 2004
Printed in Korea