Академический Документы
Профессиональный Документы
Культура Документы
This is the FlashTool In this folder is the complete system Android folder incl. scatter.txt Database for IMEI Tool
Important: Note your IMEI Number !!! The IMEI Number is behind the battery in the phone
9. You can set the format length according to the size of the Rom of your phone. If the rom is 256 M, you can set it to 0x10000000. If the rom is 512 M, you can set it to 0x20000000. 10. Please select OK, when you finish the setting. 11. Connect the flex cable from your phone to the PC. Your phone should be off power at this moment. 12. press and hold the power key on your phone until the progress bar start to move.(If the progress bar hasnt moved, you just to remove the battery and put it on again to try.) The green progress bar takes app. 7-8 minutes. Hold the powerkey all the times. 13.It will pop up the OK when the setting have finished.
1. Select Android on the point 1 2. Please note the point 2, here is set to the T6516_Android_scatter.txt, this software is a loader file which is to guide the whole flashing process. 3. In general, we provided Android rom will have this file. Please use the file within the Android Rom instead of the same name file of the kit. 4. Finally, according to the chart above to do the settings of each file for the Android. Double-click the file name, it will pop up the file selection box. 5. Please Double-click the UBOOT of point 3 and select the file with uboot as prefix within the rom package if the point 3 cant load the file automatically.
Install the driver of MTK usb( If you have finished this setting, please do the next steps)
Please click the download( Please plug the special flex cable of 2303 and regular data cable to the PC, because you need to use the data cable during the flexing.) Now press and hold the power key on your phone until the progress bar start to move.( If the progress bar doesnt move, you just to remove the battery and put it on to try again.) Please plug the data cable after the progress bar finished 2 times 100%. Now the PC will tell you it had found the new hardware of mt6516. Now you need to use the driver of mtk usb. During setting the driver, it just can appear this driver The mt6516 will only show up for one minute. If you see it was gone from the list of device manager, please remove the data cable and then plug it again, then mt6516 will be shown up again When the driver has been installed, remove the USB data cable and then plug it again. Now you should be able to find the usb modem driver in the PC device manager, that means the driver has been installed successfully. 5Flex the Android Please click the download( Please plug the special flex cable of 2303 and regular data cable to the PC, because you need to use the data cable during the flexing.) Now press and hold the power key on your phone until the progress bar start to move.( If the progress bar doesnt move, you just to remove the battery and put it on to try again.) Please plug the USB after the progress bar finished 2 times 100%. It will pop up the OK when the flexing is completed.
Before the yellow bar start, you have to look here ! Because after the red and the purple bar you have only 5 Seconds to plug in the USB Data Cable. So you use the flashcable and the USB Datacable at the same time. If it was finish there popup a OK Kongratulation
The next step is to write the IMEI into the phone The IMEI Number is behind the battery in the phone
remove the battery, connect the flex cable from your phone to the PC.
1234567891011 1234567891011
For example
press enter, press and hold the power key on your phone after inserting the battery, then you can see the meta mode in the left botton corner on your phone
Wait for this picture as blew appeared on your PC, then the IMEI flexing process is finished. If all is fine, you phone looks like mine