Вы находитесь на странице: 1из 2

Appendix B THE PRE-REDUCTION UNIT MODEL The pre-reduction unit (PRU) is semi-empirical, and assumes that true equilibrium

does not exist between the gas derived from the combustion of the PF and the composite pellets. It assumes that the PF, the carbon combusted, the carbon monoxide generated within the pellet, and the air reach equilibrium at a specified operating temperature with a resulting overall CO/CO2 ratio. The chromium and iron oxide reduction levels are specified in the program input, and are not calculated predicatively. The degree of reduction in the pellet input stream fixes the composition of the metal and the remaining oxide phases in the solids stream, and an energy balance between the input and output streams specifies the energy input required to maintain the balance. A flow sheet of the PRU model is given in figure B-1 The following assumption and process specification were made for the PRU MODEL. (i) (ii) For unfluxed pellets, the heat losses from the kiln are 4500 kW for the operating temperature of 1400 c. Fluxed pellets require a lower operating temperature of 1300 c, so the heat losses are lower (4000 kW). For the lower operating temperature, the off- gas temperature is reduced from 1000 to 900 c. There is no oxidation of the carbon contained in the pellet by the carbon dioxide present in the process gas. There is no pre-heating of the pellets; the pellets combustion coal, and air are introduced at 250 c. The coal ash leaves the kiln at the sane temperature at the off-gas. The pellets are discharged at the process temperature. The term pre-reduction is associated is removed divided by the original removable of oxygen from the oxidic iron and chromium species in the chrome spinal, and is defined as: Pre-reduction mass of oxygen removed divided by the original removable oxygen in iron and chromium species, and multiplied by 100. The original removable oxygen per unit mass of chromite ore is therefore dependent on the relative proportion of FAO, Fe2o3, and Cr2O3, as determined by chemical analysis. The 60, 65 and 80 percent pre-reduction levels considered in figure 11 correspond to iron and chromium reduction levels on 95 and 47, 97 and 54, and 99 and 73, percent respectively.

(iii) (iv) (v) (vi)

Lampiran B MODEL UNIT PRA-PENGURANGAN Unit pra-reduksi (PRU) adalah semi-empiris, dan mengasumsikan bahwa tidak ada kesetimbangan antara gas yang berasal dari pembakaran PF dan pelet komposit. Ini mengasumsikan bahwa PF, karbon dibakar, karbon monoksida yang dihasilkan dalam pelet, dan jangkauan keseimbangan udara pada suhu operasi yang ditentukan dengan rasio yang dihasilkan CO/CO2 secara keseluruhan. Tingkat oksida kromium dan reduksi besi yang ditentukan dalam program masukan, dan tidak dihitung secara predicatively. Tingkat pengurangan reduksi dalam aliran masukan pellet input stream pelet perbaiki komposisi logam dan fase oksida yang tersisa dalam aliran padatan, dan keseimbangan energi antara input dan output stream menentukan input energi yang dibutuhkan untuk menjaga keseimbangan.

Lembar aliran model PRU diberikan dalam gambar B-1 Spesifikasi asumsi dan proses mengikuti dibuat untuk MODEL PRU. (I) Untuk pelet unfluxed, kerugian panas dari kiln adalah 4500 kW untuk suhu operasi dari 1400 c. (Ii) pelet fluxed memerlukan suhu operasi yang lebih rendah dari 1300 c, sehingga kehilangan panas lebih rendah (4000 kW).Untuk suhu operasi yang lebih rendah, suhu off-gas berkurang 1000-900 c. (Iii) Tidak ada oksidasi karbon yang terkandung dalam pelet oleh adanya karbon dioksida dalam gas proses. (Iv) Tidak ada pra-pemanasan pelet; pelet pembakaran batubara, dan udara diperkenalkan pada 250 c. (V) abu batubara meninggalkan kiln pada suhu waras di off-gas. (Vi) pelet dibuang pada suhu proses. Istilah pra-reduksi dikaitkan dengan pengeluaran oksigen asli dari besi oxidic dan spesies kromium dalam bagian belakang krom, dan didefinisikan sebagai: Pra-pengurangan massa oksigen dihapus dibagi dengan pelepasan oksigen asli dalam zat besi dan spesies kromium, dan dikalikan dengan 100. pelepasan Oksigen asli per satuan massa bijih kromit karena itu tergantung pada proporsi relatif dari FAO,, Fe2O3 dan Cr2O3, sebagaimana ditentukan oleh analisis kimia. 60 persen, 65 dan 80 persen tingkat pra-pengurangan dipertimbangkan dalam gambar 11 sesuai dengan tingkat pengurangan besi dan kromium pada 95 dan 47, 97 dan 54, dan 99 dan 73, persen.

Вам также может понравиться