Академический Документы
Профессиональный Документы
Культура Документы
System Administration
> Upon completion of this module, you should be familiar with the following:
Out-of-Box Experience (OBE) Initial System Setup Tasks System Navigation System Upgrades/Updates System Snapshots Monitoring User Administration
> TOS User vs. Local User
OBE
OBE
Security Level
OBE
OBE
Setup Command
> After completing OBE, connect to the management port or default LAN interface to begin managing your device > Alternatively, configuration changes can be made in the CLI to assign IP addresses > By default the WAN interface is configured as a DHCP client > By default the LAN interface is configured with the IP address 192.168.1.254/24
LAB 1 OBE
11
Page Layout
12
13
14
> TippingPoint OS (TOS) updates are released periodically for major version changes and maintenance releases > Digital Vaccine (DV) updates are released on a weekly basis, or as dictated by the severity of a new exploit/vulnerability
15
> TOS Updates must be performed manually > DV Updates can be performed manually or automatically (recommended)
16
System Snapshots
> Snapshots are backups of your X505 configuration > The current DV is included in the backup
> Click the Floppy Disk icon to save snapshots to disk > Click the Recycle icon to restore a Snapshot
17
System Monitoring
18
Authentication
19
User Administration
20
Administrator
All All All All All
Super-User
All All All All All
View and run tools (Traffic Capture, Traceroute, Ping) All but Audit Log
All
All
Privilege Groups
22
> Combination of Privilege Groups and Firewall Rules allow finite control over who can access what and when
Allow: Web & Email
Internet
Teachers
Faculty LAN
Students
Student LAN
23
24
25
> The Command Line Interface (CLI) can be used to configure your X505 out of the box as well as routine system configuration tasks > Most system configuration changes are made by prefixing each command with a configure terminal or config t > Use the show command to see system/configuration information > Use the ? to show which commands are available
26
> Press TAB to complete commands > Press ? to see available commands
27
Factory Reset
> Set the X505 back to factory configuration, including TOS and DV
28