Академический Документы
Профессиональный Документы
Культура Документы
How to make briquettes with durian skin as base material is as follows: A. Equipment The blades / cutters to chop / chop durian skin Drum used for furnace Sieve or strainer Mixer Wooden Grinder Molding Basin for Mixing Zinc for drying 2. Material Durian Skin Leaves or straw Wheat starch (sago) Water 3. Step Work Previously Durian skin is cut into pieces or chopped, chop up a bit smaller in size in order to burn more quickly later. After it is chopped or minced and then dried in the sun on a bed of zinc heated to the drying process faster. Then prepare the drum on a flat ground , enter the twigs or straw first, followed by the skin has been sun-dried then insert a pile of straw or twigs but not too thick, burn the haystack and durian skin, cover with lid and create small holes in order to burn evenly and when there is no smoke coming out of the hole to open the lid and stir to make sure it has a charcoal, the combustion process should not be too long. Lift and separate the combustion products before, which has been filtered and separated into charcoal, then ground to a fine and sifted or powdered charcoal for obtaining a uniform size. The next step is put into the basin , take a little flour (not too much to just 15% only) flour is used as a glue, and stir until evenly distributed, then enter the water gradually while stirring (the water is given just 10% only) stir until the dough is really distributed. Take the mold if there is no mold ,use your hands to print, which is mold, the way to mold it is to let the ingredient into it and let it dry , For hands. You can mold it according to the desired shape (round, oval, plots, etc.) from less dense and tight. Dough that has been printed are going to dried on open sun beneatht the zinc , dried for 1/2 hours depending on the weather that support until it is completely dry. After the last step is dried up and stored in a place that is not humid.