Академический Документы
Профессиональный Документы
Культура Документы
An example of PWM: the supply voltage (blue) modulated as a series of pulses results in a sine-like flux density waveform (red) in a magnetic circuit of electromagnetic actuator. The smoothness of the resultant waveform can be controlled by the width and number of modulated impulses (per given cycle)
PRINCIPLE
Pulse-width modulation uses a square wave whose pulse width is modulated resulting in the variation of the average value of the waveform.
If we consider a square waveform f(t) with a low value ymin, a high value ymax and a duty cycle D (see figure), the average value of the waveform is given by: y = 1/T 0T f(t) dt As f(t) is a square wave, its value is ymax for 0<t<D.T and ymin for D.T<t<T . The above expression then becomes: y = 1/T ( 0DT ymax dt + DTT ymin dt) = DTymax + T(1-D)ymin T = D.ymax + (1-D).ymin This latter expression can be fairly simplified in many cases where ymin = 0 as y = D. ymax
From this, it is obvious that the average value of the signal () is directly dependent on the duty cycle D.
DELTA PWM
The output signal is compared with limits, which correspond to a reference signal offset by a constant. Every time the output signal reaches one of the limits, the PWM signal changes state.
SIGMA-DELTA PWM
The output signal is subtracted from a reference signal to form an error signal. This error is integrated, and when the integral of the error exceeds the limits, the output changes state.
DIGITAL PWM
Many digital circuits can generate PWM signals (e.g many microcontrollers have PWM outputs). They normally use a counter that increments periodically (it is connected directly or indirectly to the clock of the circuit) and is reset at the end of every period of the PWM. When the counter value is more than the reference value, the PWM output changes state from high to low (or low to high).
TYPES OF PWM
Three types of pulse-width modulation (PWM) are possible: Centered Pulse Modulation: The pulse center may be fixed in the center of the time window and both edges of the pulse moved to compress or expand the width. Leading Edge Modulation: The lead edge can be held at the lead edge of the window and the tail edge modulated. Trailing Edge Modulation: The tail edge can be fixed and the lead edge modulated.
APPLICATIONS
1. TELECOMMUNICATIONS:
In telecommunications, the widths of the pulses correspond to specific data values encoded at one end and decoded at the other. Pulses of various lengths (the information itself) will be sent at regular intervals (the carrier frequency of the modulation).
2. POWER DELIVERY:
PWM can be used to reduce the total amount of power delivered to a load without losses normally incurred when a power source is limited by resistive means. This is because the average power delivered is proportional to the modulation duty cycle. With a sufficiently high modulation rate, passive electronic filters can be used to smooth the pulse train and recover an average analog waveform.
3. VOLTAGE REGULATION:
PWM is also used in efficient voltage regulators. By switching voltage to the load with the appropriate duty cycle, the output will approximate a voltage at the desired level. The switching noise is usually filtered with an inductor and a capacitor. One method measures the output voltage. When it is lower than the desired voltage, it turns on the switch. When the output voltage is above the desired voltage, it turns off the switch.