Вы находитесь на странице: 1из 88

Internal

OptiX OSN 1500250035007500 Ethernet Services Configuration (Manual Configuration)


www.huawei.com

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Upon completion of this course, you will be

able to:
Explain the menu of iManager T2000 for Ethernet Services

Describe the process of configuring Ethernet Services on the T2000


Learn how to configure Ethernet Services

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 1

Chapter 1 The Basic Concepts


Chapter 2 The EPL Service Configuration Chapter 3 The EPLAN Service Configuration Chapter 4 The EVPL Service Configuration

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 2

Parameters for the Ethernet interface


Tag flag:
Tag flag is used to identify the type of packets. Three types of TAG flags

are available: tag aware, access, and hybrid. Tag Aware: When the port is set to be tag aware, the port transmits the packets with the Tag flag transparently and discards those without the Tag flag

Access: When the port is set to be access, the port attaches a Tag flag to the packets without Tag flag according to its VLAN ID and discards those with the Tag flag.
Hybrid: When the port is set to be hybrid, the port can process packets regardless of the Tag flag and attach a Tag flag to the packets without the Tag flag according to its VLAN ID.

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 3

Parameters for the Ethernet interface

Packets Port Tag aware (In) Tag aware (Out) Access (In) Access (Out) Hybrid (In)

Tag flag Transmit transparently Transmit transparently discard Delete the Tag flag (default Vlan) Transmit transparently If Vlan is the same, delete the Tag flag, otherwise transmit transparently

Untag flag discard attach a Tag flag (default Vlan) attach a Tag flag (default Vlan)

Hybrid (Out)

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 4

Parameters for the Ethernet interface


VLAN ID:

VLAN ID of the port (MAC or VCTRUNK).


Working mode:

It can be set to auto-negotiation, 10 Mbit/s half/full-duplex, 100 Mbit/s half/full-duplex or 1 Gbit/s full-duplex. The Ethernet interfaces of the interconnected equipment should work under the same fixed working mode; otherwise, the packet may be lost and the rate may decrease, or the service may be completely interrupted upon large volume of traffic.
Port type:

There are two types: P and PE. Provider edge (PE) is the marginal port of the service provider. Provider (P) is the core network port of the service provider. Port type is needed when configuring EVPL and EVPLAN services.

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 5

Parameters for the Ethernet interface


LCAS enable:

Maximum packet length:


Whether to enable LCAS.

Set this item for the external port, 1522 bytes by default.
Mapping protocol:

It is preferable to select the default- GFP mapping protocol.

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 6

Ethernet Services Types

EPL: Ethernet Private Line Service.

EPLAN: Ethernet Private LAN Service . EVPL: Ethernet Virtual Private Line Service. EVPLAN: Ethernet Virtual Private LAN Service.

Reference: G.8010 /Y.1306 (G.ethna),

G.8011 (G.ethsrv),
G.8012.1 (G.eota.1).
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 7

Chapter 1 The Basic Concepts


Chapter 2 The EPL Service Configuration Chapter 3 The EPLAN Service Configuration Chapter 4 The EVPL Service Configuration

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 8

Configuring the EPL Service


For EPL Service, there are three types:

the Point-to-Point EPL Service the MAC Shared EPL Service the VCTRUNK Shared EPL Service

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 9

Configuring the EPL Service

Configuring the Point-to-Point EPL Service:

Engineering Requirements
Engineering Planning Configuration Process

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 10

Configuring the EPL Service


Configuring the Point-to-Point EPL Service:

User
A B

Service requirement
Point-to-point Point-to-point

Source station
NE1 NE1

Sink station
NE5 NE5

Bandwidth
10 Mbit/s 40 Mbit/s

T2000 NE1 NE2 STM-16two-fiber bidirectional MSP ring NE4 NE3

Engineering Requirements
STM-4two-fiber bidirectional nonprotection chain NE5

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 11

Configuring the EPL Service


Configuring the Point-to-Point EPL Service:

Engineering Planning

Step 1: Networking Diagram


Step 2: Board Information of Each NE Step 3: Service Configuration Diagram of Each NE Step 4: Timeslot Allocation Diagram

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 12

Configuring the EPL Service


Step 1: Networking Diagram
A B

MAC1

MAC2

T2000 NE1 STM-16 two-fiber bidirectional MSP ring STM-4 two-fiber bidirectional nonprotection chain NE5 NE4
MAC1 MAC2

NE2

NE3 A VC-Trunk Company A Service Company B Service HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 13 B

Configuring the EPL Service


Step 2: Board Information of Each NE
Board layout of NE1

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 14

Configuring the EPL Service


Step 2: Board Information of Each NE
Board layout of NE5

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 15

Configuring the EPL Service


Step 3: Service Configuration Diagram of Each NE

MAC

VCTRUNK

VCTRUNK

MAC

A B

MAC1

MAC1 VCTRUNK1
VC4-4:VC12-1~VC12-5

10M
MAC2

SDH

VCTRUNK1
VC4-4:VC12-1~VC12-5

10M
MAC2

A B

40M

VCTRUNK2
VC-4-1:VC-3-1

VCTRUNK2
VC-4-1:VC-3-1

40M

NE1

NE5

Service configuration diagram

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 16

Configuring the EPL Service


Step 3: Service Configuration Diagram of Each NE
Service Attribute
Source NE Source board - port Source timeslot Source VCTRUNK Working mode of source MAC port TAG flag of source MAC port VLAN ID of source MAC port Bound bandwidth Sink NE Sink board - port Sink timeslot Sink VCTRUNK Working mode of sink MAC port TAG flag of sink MAC port VLAN ID of sink MAC port

A
NE1 13-N1EFS4-1 VC4-4: VC12-1VC12-5 VCTRUNK1 (Tag aware) Auto negotiation Access 1 5 x VC-12 NE5 15-N1EFS4-1 VC4-4: VC12-1VC12-5 VCTRUNK1 (Tag aware) Auto negotiation Access 1

B
NE1 13-N1EFS4-2 VC4-1: VC3-1 VCTRUNK2 (Tag aware) Auto negotiation Access 2 1 x VC-3 NE5 15-N1EFS4-2 VC4-1: VC3-1 VCTRUNK2 (Tag aware) Auto negotiation Access 2

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 17

Configuring the EPL Service


Step 4: Timeslot Allocation Diagram
Ring Station NE1 12-SL16-1 Timeslot VC-4-3 NE4 NE2 NE3 7-SL16-1 12-SL16-1 7-SL16-1 12-SL16-1 7-SL16-1 12-SL16-1 NE1 7-SL16-1

VC-12: 1-5 13-EFS4: VC4-4 VC-3: 1

VC-4-4

13-EFS4: VC-4-1

Chain Station NE4 13-SL4-1


VC-4-3

NE5 7-SL4-1

VC-12: 1-5 15-EFS4: VC4-4 VC-3: 1 15-EFS4: VC-4-1 Forward Add/Drop

VC-4-4

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 18

Configuring the EPL Service


Configuring the Point-to-Point EPL Service:

Configuration Process

Step 1: Creating a board


Step 2: Configuring Ethernet interfaces Step 3: Configuring binding paths

Step 4: Creating the point-to-point EPL service


Step 5: Configuring committed access rate (CAR) (Optional ) Step 6: Configuring the cross-connect from Ethernet boards to SDH line boards

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 19

Configuring the EPL Service


Step 1: Creating a board

Right click

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 20

Configuring the EPL Service


Step 2: Configuring Ethernet interfaces

Left click Left click Right click

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 21

Configuring the EPL Service


Step 3: Configuring binding paths

Left click Left click

Left click Left click


HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 22

Configuring the EPL Service


Step 4: Creating the point-to-point EPL service

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved

Left click
Page 23

Step 4: Configuring committed access rate (CAR) (Optional )

Configuring the EPL Service

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 24

Left click

Configuring the EPL Service


Step 6: Configuring the cross-connect from Ethernet boards to SDH line boards

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved

Left click Left click


Page 25

Summary
Creating an Ethernet board Configuring Ethernet interfaces

External Port: Basic Attributes, Tag Attribute


Internal Port: Tag Attribute, LCAS
Configuring binding paths:

Configurable Ports, Level, Direction, Available VC4, timeslots


Creating the MAC shared EPL service:

Service Type, Service Direction, Ports, VLAN, TAG, Port Type


Configuring committed access rate (CAR):

CAR ID, Capacity, Ports


Configuring the cross-connect from Ethernet boards to SDH line boards

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 26

Configuring the EPL Service


For EPL Service, there are three types:

the Point-to-Point EPL Service the MAC Shared EPL Service the VCTRUNK Shared EPL Service

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 27

Configuring the EPL Service


Configuring the MAC Shared EPL Service :

Engineering Requirements

Engineering Planning
Configuration Process

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 28

Configuring the EPL Service


Configuring the MAC Shared EPL Service:
Source User Service requirement Source station Sink User Sink station Bandwidth

C
C

MAC Shared
MAC Shared

NE1
NE1

C(1)
C(2)

NE5
NE5

10 Mbit/s
10 Mbit/s

Engineering Requirements
T2000
NE1 NE2 STM-16 two-fiber bidirectional MSP ring NE4 NE3 STM-4two-fiber bidirectional nonprotection chain NE5

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 29

Configuring the EPL Service


Engineering Planning

Configuring the MAC Shared EPL Service : Step 1: Networking Diagram Step 2: Board Information of Each NE Step 3: Service Configuration Diagram of Each NE Step 4: Timeslot Allocation Diagram

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 30

Configuring the EPL Service


Step 1: Networking Diagram

C (Headquarters) NE1 T2000


MAC1 MAC2 MAC3

C(1)
MAC3

C(2)
MAC4

NE2

NE4
MAC1

NE5
MAC2

NE3 A B

VC-Trunk

C & C(1) Service C & C(2) Service HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 31

Configuring the EPL Service


Step 2: Board Information of Each NE
NE1 and NE5 do not require any new board.

Step 3: Service Configuration Diagram of Each NE


MAC VCTRUNK

VCTRUNK

MAC

A B

MAC1

MAC1 VCTRUNK1
VC4-4:VC12-1~VC12-5

10M
MAC2

VCTRUNK1
VC4-4:VC12-1~VC12-5

10M
MAC2

A B

40M

VCTRUNK2
VC-4-1:VC-3-1

SDH

VCTRUNK2
VC-4-1:VC-3-1

40M
MAC3

MAC3

VCTRUNK3
VC4-4:VC12-6~VC12-10

VCTRUNK3
VC4-4:VC12-6~VC12-10

10M
MAC4

C1 C2

VCTRUNK4
VC4-4:VC12-11~VC12-15

VCTRUNK4
VC4-4:VC12-11~VC12-15

10M NE5

NE1

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 32

Configuring the EPL Service


Step 3: Service Configuration Diagram of Each NE
Service Attribute
Source NE Source board - port Source timeslot Source VCTRUNK Working mode of source MAC port TAG flag of source MAC port VLAN ID of source MAC port Bound bandwidth Sink NE Sink board - port Sink timeslot Sink VCTRUNK 15-N1EFS4-3 VC4-4: VC12-6VC12-10 VCTRUNK3 (Tag aware)

C & C(1)
NE1 13-N1EFS4-3 VC4-4: VC12-6VC12-10 VCTRUNK3 (Tag aware) Auto negotiation Tag aware 3 5 x VC-12 NE5

C & C(2)

VC4-4: VC12-11VC12-15 VCTRUNK4 (Tag aware) Auto negotiation Tag aware 4 5 x VC-12

15-N1EFS4-4 VC4-4: VC12-11VC12-15 VCTRUNK4 (Tag aware)

Working mode of sink MAC port


TAG flag of sink MAC port VLAN ID of sink MAC port

Auto negotiation
Access 3

Auto negotiation
Access 4

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 33

Configuring the EPL Service


Step 4: Timeslot Allocation Diagram
Ring NE4 NE1 NE2 NE3 12-SL16-1 7-SL16-1 12-SL16-1 7-SL16-1 12-SL16-1 7-SL16-1 Timeslot 12-SL16-17-SL16-1 VC-12: 6-15 VC-4-3 13-EFS4: VC4-4 Chain StationNE4 NE5 13-SL4-1 7-SL4-1 Station NE1

VC-4-3

VC-12: 6-15 15-EFS4: VC4-4

Forwared Add/Drop
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 34

Configuring the EPL Service


Configuring the MAC Shared EPL Service:

Configuration Process
Step 1: Creating a board (None) Step 2: Configuring Ethernet interfaces Step 3: Configuring binding paths Step 4: Creating the MAC shared EPL service Step 5: Configuring committed access rate (CAR) (Optional Step 6: Configuring the cross-connect from Ethernet boards to SDH line boards
Notice: We dont need the first step because the Ethernet boards Have already been created.

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 35

Configuring the EPL Service


Step 2: Configuring Ethernet interfaces

Right click Left click

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 36

Configuring the EPL Service


Step 3: Configuring binding paths

Left click Left click

Left click Left click


HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 37

Configuring the EPL Service


Step 4: Creating the MAC shared EPL service

Left click
HUAWEI TECHNOLOGIES CO., LTD.

Left click
Page 38

All rights reserved

Configuring the EPL Service


Step 5: Configuring committed access rate (CAR) (Optional Step 6: Configuring the cross-connect from Ethernet boards to

SDH line boards

Notice: These two steps are the same as that of the point-to-point EPL service, except that some

parameters are different.

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 39

Summary
Creating an Ethernet board Configuring Ethernet interfaces

External Port: Basic Attributes, Tag Attribute

Internal Port: Tag Attribute, LCAS


Configuring binding paths:

Configurable Ports, Level, Direction, Available VC4, timeslots


Creating the MAC shared EPL service:

Service Type, Service Direction, Ports, VLAN, TAG, Port Type


Configuring committed access rate (CAR):

CAR ID, Capacity, Ports


Configuring the cross-connect from Ethernet boards to SDH line boards

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 40

Configuring the EPL Service


For EPL Service, there are three types:

the Point-to-Point EPL Service the MAC Shared EPL Service the VCTRUNK Shared EPL Service

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 41

Configuring the EPL Service

Configuring the VCTRUNK Shared EPL Service :

Engineering Requirements Engineering Planning Configuration Process

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 42

Configuring the EPL Service


Configuring the VCTRUNK Shared EPL Service:
Source User
D E

Service requirement
VCTRUNK Shared VCTRUNK Shared

Source station
NE2 NE2

Sink User
D E

Sink station
NE3 NE3

Bandwidth
300 Mbit/s 300 Mbit/s

T2000 NE1 NE2 STM-16 two-fiber bidirectional MSP ring NE4 NE3

Engineering Requirements
STM-4 two-fiber bidirectional non- protection chain NE5

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 43

Configuring the EPL Service


Configuring the VCTRUNK Shared EPL Service :

Engineering Planning Step 1: Networking Diagram Step 2: Board Information of Each NE

Step 3: Service Configuration Diagram of Each NE


Step 4: Timeslot Allocation Diagram

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 44

Configuring the EPL Service


Step 1: Networking Diagram

NE1 T2000
MAC1

NE2

NE4 NE5

MAC2

NE3
MAC1 MAC2

VC-Trunk

D & D Service
E & E Service

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 45

Configuring the EPL Service


Step 2: Board Information of Each NE
Board layout of NE2 and NE3

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 46

Configuring the EPL Service


Step 3: Service Configuration Diagram of Each NE
MAC VCTRUNK VCTRUNK MAC
MAC1
300M VCTRUNK1
VC4-1:VC3-1~VC3-3 VC4-2:VC3-1~VC3-3

D E

MAC1
300M

D E

MAC2
300M

VCTRUNK1

MAC2
300M

SDH

VC4-1:VC3-1~VC3-3 VC4-2:VC3-1~VC3-3

NE2

NE3

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 47

Configuring the EPL Service


Step 3: Service Configuration Diagram of Each NE
Service Attribute
Source NE Source board - port Source timeslot 13-N1EGS2-1

D
NE2

E
13-N1EGS2-2

VC4-1: VC3-1VC3-3, VC4-2: VC3-1VC3-3

Source VCTRUNK
Working mode of source MAC port TAG flag of source MAC port VLAN ID of source MAC port

VCTRUNK1 (Tag aware)


1000M full duplex Access 1 1000M full duplex Access 2

Bound bandwidth
Sink NE Sink board - port Sink timeslot 13-N1EGS2-1

6 x VC-3
NE3 13-N1EGS2-2

VC4-1: VC3-1VC3-3, VC4-2: VC3-1VC3-3

Sink VCTRUNK
Working mode of sink MAC port TAG flag of sink MAC port VLAN ID of sink MAC port

VCTRUNK1 (Tag aware)


1000M full duplex Access 1 1000M full duplex Access 2

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 48

Configuring the EPL Service


Step 4: Timeslot Allocation Diagram
Ring Station NE1 12-SL16-1 Timeslot VC-4-3 NE4 NE2 NE3 7-SL16-1 12-SL16-1 7-SL16-1 12-SL16-1 7-SL16-1 12-SL16-1 VC-3: 1-3 13-EGS2: VC4-1 VC-3: 1-3 VC-4-4 13-EGS2: VC4-2 Forward Add/Drop NE1 7-SL16-1

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 49

Configuring the EPL Service


Configuring the VCTRUNK Shared EPL Service:

Configuration Process Step 1:Creating a board Step 2: Configuring Ethernet interfaces Step 3: Configuring binding paths

Step 4: Creating the VCTRUNK shared EPL service


Step 5: Configuring committed access rate (CAR) (Optional ) Step 6: Configuring the cross-connect from Ethernet boards to SDH line boards
Notice: The steps are the same as the MAC shared EPL Service.
So here we dont need introduce them again.
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 50

Summary
Creating an Ethernet board Configuring Ethernet interfaces

External Port: Basic Attributes, Tag Attribute Internal Port: Tag Attribute, LCAS Configuring binding paths: Configurable Ports, Level, Direction, Available VC4, timeslots Creating the VCTRUNK shared EPL service: Service Type, Service Direction, Ports, VLAN, TAG, Port Type Configuring committed access rate (CAR): CAR ID, Capacity, Ports Configuring the cross-connect from Ethernet boards to SDH line boards

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 51

Chapter 1 The Basic Concepts


Chapter 2 The EPL Service Configuration Chapter 3 The EPLAN Service Configuration Chapter 4 The EVPL Service Configuration

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 52

Configuring the EPLAN Service


Configuring the EPLAN Service:

Engineering Requirements Engineering Planning Configuration Process

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 53

Configuring the EPLAN Service


Engineering Requirements

T2000 NE1 STM-16two-fiber bidirectional MSP ring NE4

STM-4 two-fiber bidirectional non- protection chain


NE5

NE2

NE3

Source User Service requirement Source station Sink User Sink station
F(1) F(3) F(1) EPLAN EPLAN EPLAN NE2 NE4 NE2 F(2) F(2) F(3) NE3 NE3 NE4

Bandwidth
10 Mbit/s 10 Mbit/s 10 Mbit/s

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 54

Configuring the EPLAN Service

Engineering Planning
Step 1: Networking Diagram Step 2: Board Information of Each NE Step 3: Service Configuration Diagram of Each NE Step 4: Timeslot Allocation Diagram

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 55

Configuring the EPLAN Service


Step 1: Networking Diagram

NE1 T2000
VCTRUNK1 VB MAC1 VB MAC1 VCTRUNK1

NE2 B
MAC1

NE4
MAC1

NE3

NE5

F(1)
MAC1
VCTRUNK1 VB

F(3) VC-Trunk
VCTRUNK2

F(1) & F(2) Service

F(2)

MAC1

F(3) & F(2) Service


F(1) & F(3) Service

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 56

Configuring the EPLAN Service


Step 2: Board Information of Each NE
Board layout of NE2 and NE3

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 57

Configuring the EPLAN Service


Step 2: Board Information of Each NE
Board layout of NE4

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 58

Configuring the EPLAN Service


Step 3: Service Configuration Diagram of Each NE
VCTRUNK
LP2

MAC
LP1MAC1
10M

MAC

VCTRUNK
LP2

F1

VCTRUNK1
VC4-4:VC12-1~VC12-5

VB1 NE2

F2

MAC1LP1
10M

VCTRUNK1

LP3

VC4-4:VC12-1~VC12-5

VB1 NE3

VC4-4:VC12-6~VC12-10

VCTRUNK2

VCTRUNK
LP2
VCTRUNK1

MAC
LP1MAC1
10M

F3

SDH

VC4-4:VC12-1~VC12-5

VB1 NE4

Service configuration diagram

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 59

Configuring the EPLAN Service


Attribute \ Service
Source NE Source board port Source timeslot Source VCTRUNK Source VCTRUNK attribute Working mode of source MAC port TAG flag of source MAC port VLAN ID of source MAC port VB Attached port Sink NE Sink board port Sink timeslot Sink VCTRUNK Sink VCTRUNK attribute Working mode of sink MAC port TAG flag of sink MAC port VLAN ID of sink MAC port Virtual bridge (VB) Attached port VC4-4: VC12-1VC12-5 VCTRUNK1 (Tag Aware) PE Auto negotiation Access 11 VB1 MAC1, VCTRUNK1, VCTRUNK2 NE2 14-N1EFS0-1 VC4-4: VC12-1VC12-5 VCTRUNK1 (Tag Aware) PE Auto negotiation Access 11 VB1 MAC1, VCTRUNK1 NE4 15-N1EFS0-1 VC4-4: VC12-1VC12-5 VCTRUNK1 (Tag Aware) PE Auto negotiation Access 11 VB1 MAC1, VCTRUNK1

F
NE3 14-N1EFS0-1 VC4-4: VC12-6VC12-10 VCTRUNK2 (Tag Aware) PE

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 60

Configuring the EPLAN Service


Step 3: Service Configuration Diagram of Each NE
NE name
NE2 NE3 NE4

VB
VB1 VB1 VB1

VLAN ID
11 11 11

Forwarding port
LP1, LP2 LP1, LP2, LP3 LP1, LP2

Ring

Step 4: Timeslot Allocation Diagram


NE1 7-SL16-1

Station NE1 NE4 NE2 NE3 Timeslot 12-SL16-1 7-SL16-112-SL16-1 7-SL16-1 12-SL16-1 7-SL16-1 12-SL16-1 VC-4-5 VC-12: 1-5 14-EFS0: VC4-4 Forward Add/Drop VC-12: 1-5 15-EFS0: VC4-4

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 61

Configuring the EPLAN Service


Configuration Process Step 1: Creating a board Step 2: Configuring Ethernet interfaces

Step 3: Configuring binding paths


Step 4: Creating the EPLAN service Step 5: Configuring the forwarding filter table Step 6: Configuring committed access rate (CAR) (Optional ) Step 7: Configuring the cross-connect from Ethernet boards to SDH line boards

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 62

Configuring the EPLAN Service


Step 1: Creating a board

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 63

Configuring the EPLAN Service


Step 2: Configuring Ethernet interfaces
Left click

Right click

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 64

Configuring the EPLAN Service


Step 3: Configuring binding paths

Left click Left click

Left click Left click


HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 65

Configuring the EPLAN Service


Step 4: Creating the EPLAN service

Left click Left click

Left click Left click


HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 66

Left click

Configuring the EPLAN Service


Step 5: Configuring the forwarding filter table

Left click

Left click Left click


HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 67

Configuring the EPLAN Service


Step 6: Configuring committed access rate (CAR) (Optional )

Left click Left click


HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 68

Configuring the EPLAN Service


Step 7: Configuring the cross-connect from Ethernet boards to SDH line boards

Left click

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 69

Summary
Creating an Ethernet board Configuring Ethernet interfaces

External Port: Basic Attributes, Tag Attribute, VLAN Internal Port: Tag Attribute, VLAN, LCAS Configuring binding paths: Configurable Ports, Level, Direction, Available VC4, timeslots Creating the EPLAN service: VB Port, Mount Port, Port Type, Binding Path Configuring the forwarding filter table VB Port, VLAN ID, forwarding port Configuring committed access rate (CAR): CAR ID, Capacity, Ports Configuring the cross-connect from Ethernet boards to SDH line boards

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 70

Chapter 1 The Basic Concepts


Chapter 2 The EPL Service Configuration Chapter 3 The EPLAN Service Configuration Chapter 4 The EVPL Service Configuration

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 71

Configuring the EVPL Service


Configuring the EVPL Service:

Engineering Requirements Engineering Planning Configuration Process

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 72

Configuring the EVPL Service


Engineering Requirements

T2000 NE1 NE2 STM-16 two-fiber bidirectional MSP ring NE4 NE3

STM-4 two-fiber bidirectional non-protection chain NE5

Source User
D E

Service requirement
EVPL EVPL

Source station
NE2 NE2

Sink User
D E

Sink station
NE3 NE3

Bandwidth
100 Mbit/s 100 Mbit/s

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 73

Configuring the EVPL Service


Engineering Planning Step 1: Networking Diagram Step 2: Board Information of Each NE Step 3: Service Configuration Diagram of Each NE Step 4: Timeslot Allocation Diagram

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 74

Configuring the EVPL Service


Step 1: Networking Diagram

NE1 T2000
MAC1

NE2

NE4 NE5

MAC2

NE3
MAC1 MAC2

VC-Trunk

D & D Service E & E Service

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 75

Configuring the EVPL Service


Step 2: Board Information of Each NE
Board layout of NE2 and NE3

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 76

Configuring the EVPL Service


Step 3: Service Configuration Diagram of Each NE

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 77

Configuring the EVPL Service


Step 3: Service Configuration Diagram of Each NE

Attribute \ Service
Source NE Source board - port Source timeslot Source VCTRUNK Source VCTRUNK attribute Working mode of source MAC port TAG flag of source MAC port VLAN ID of source MAC port Source MAC attribute Bound bandwidth Sink NE Sink board - port Sink timeslot Sink VCTRUNK Sink VCTRUNK attribute Working mode of sink MAC port TAG flag of sink MAC port VLAN ID of sink MAC port Sink MAC attribute

D
NE2 14-N1EFS0-1

E
14-N1EFS0-2

VC4-4: VC12-1VC12-48 VCTRUNK1 (Tag Aware ) P 100M full duplex 100M full duplex Tag Aware Tag Aware 11 11 PE PE 48 x VC-12 NE3 14-N1EFS0-1 14-N1EFS0-2 VC4-4: VC12-1VC12-48 VCTRUNK1 (Tag Aware ) P 100M full duplex 100M full duplex Tag Aware Tag Aware 11 11 PE PE

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 78

Configuring the EVPL Service


Step 3: Service Configuration Diagram of Each NE
NE name VCTRUNK-MAC (path) VCTRUNK1-MAC1 VCTRUNK1-MAC2 multi-protocol label switching (MPLS) Tunnel 55 66 VC 25 26

NE2 \ NE3 NE2 \ NE3

Step 4: Timeslot Allocation Diagram


Station Timeslot NE1 NE2 NE3 12-SL16-1 7-SL16-1 VC12: 1-48 NE4 12-SL16-1 7-SL16-1 NE1 12-SL16-1 7-SL16-1

12-SL16-1 7-SL16-1

VC4-4
14EFS0: VC4-4

Forward

Add/Drop
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 79

Configuring the EVPL Service


Configuration Process Step 1: Creating a board Step 2: Configuring Ethernet interfaces Step 3: Configuring binding paths Step 4: Creating the EVPL service Step 5: Configuring committed access rate (CAR) (Optional ) Step 6: Configuring the cross-connect from Ethernet boards to SDH line boards

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 80

Configuring the EVPL Service


Step 1: Creating a board

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 81

Configuring the EVPL Service


Step 2: Configuring Ethernet interfaces

Left click

Right click

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 82

Configuring the EVPL Service


Step 3: Configuring binding paths

Left click Left click

Left click Left click


HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 83

Configuring the EVPL Service


Step 4: Creating the EVPL service

Left click
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 84

Left click Left click

Configuring the EVPL Service

Step 5: Configuring committed access rate (CAR) (Optional ) Step 6: Configuring the cross-connect from Ethernet boards to SDH line boards

Notice: These two steps are the same as that of the EPL service, except that some parameters are different.

HUAWEI TECHNOLOGIES CO., LTD.

All rights reserved

Page 85

Summary
Creating an Ethernet board Configuring Ethernet interfaces

External Port: Basic Attributes, Tag Attribute, VLAN Internal Port: Tag Attribute, VLAN, LCAS, MPLS
Configuring binding paths:

Configurable Ports, Level, Direction, Available VC4, timeslots


Creating the EVPL service:

Service Type, Service Direction, Ports, TAG, VLAN, Tunnel, VC, Port Type, Encapsulation Format
Configuring committed access rate (CAR):

CAR ID, Capacity, Ports

Configuring the cross-connect from Ethernet boards to SDH line boards


All rights reserved Page 86

HUAWEI TECHNOLOGIES CO., LTD.

Thank You
www.huawei.com

Вам также может понравиться