Академический Документы
Профессиональный Документы
Культура Документы
Effects of an
Explosion
Classification of
Explosives
Low Explosives
High Explosives
Primary
Secondary
Conclusion
When an explosive is
detonated, the
material is instantly
converted from a
solid into a mass of
rapidly expanding
gases.
Causes 3 primary
effects:
Blast pressure
Fragmentation
Thermal effects
TakeninpartfromaseminarbyJimKahoeandGregBrown
Order of Priorities
Priority
1
2
3
4
5
6
7
8
9
Order of Priorities
Priority
A
B
C
D
E
F
The potential of an explosive is the total work that can be performed by the gas
resulting from its explosion, when expanded adiabatically from its original volume, until
its pressure is reduced to atmospheric pressure and its temperature to 15 C. The
potential is therefore the total quantity of heat given off at constant volume when
expressed in equivalent work units and is a measure of the strength of the explosive.
An explosion may occur under two general conditions: the first, unconfined, as in the
open air where the pressure (atmospheric) is constant; the second, confined, as in a
closed chamber where the volume is constant. The same amount of heat energy is
liberated in each case, but in the unconfined explosion, a certain amount is used as
work energy in pushing back the surrounding air, and therefore is lost as heat. In a
confined explosion, where the explosive volume is small (such as occurs in the
powder chamber of a firearm), practically all the heat of explosion is conserved as
useful energy. If the quantity of heat liberated at constant volume under adiabatic
conditions is calculated and converted from heat units to equivalent work units, the
potential or capacity for work results.
9
Qmp represents the total quantity of heat given off by a gram molecule of explosive of 15 C and constant pressure
(atmospheric);
Qmv represents the total heat given off by a gram molecule of explosive at 15 C and constant volume; and
W represents the work energy expended in pushing back the surrounding air in an unconfined explosion and thus is not available
as net theoretical heat;
Then, because of the conversion of energy to work in the constant pressure case,
Qmv = Qmp + W
Qmp = ( viQfi - vkQfk )
where:
Qfi = heat of formation of product i at constant pressure
Qfk = heat of formation of reactant k at constant pressure
v = number of mols of each product/reactants (m is the number of products and n the number of reactants)
The work energy expended by the gaseous products of detonation is expressed by:
W = Pdv
W = (10.132 x 104 N)(23.63 l)(Nmol)(10-3m3)
W = (0.572)(Nmol) kcal mol
10
For TNT:
C6H2(NO2)3CH3 ->
with Nmol =
11
For TNT:
C6H2(NO2)3CH3 -> 6CO + 2.5H2 + 1.5N2 + C
with Nmol = 10 mol
Then:
Qmp = 6(26.43) -16.5 = 142.08 kca /l mol
Note: Elements in their natural state (H2, O2, N2, C, et,.) are used as the basis
for heat of formation tables and are assigned a value of zero.
Qmv = 142.08 + 0.572(10) = 147.8 kcal / mol
12
13
Example
The PETN reaction will be examined as an example of thermo-chemical calculations.
PETN: C(CH2ONO2)4
MW = 316.15 Heat of Formation = 119.4 kcal/mol
(1) Balance the chemical reaction equation. Using priorities in order decide reaction products:
5C + 12O -> 5CO + 7O
Next, the hydrogen combines with remaining oxygen:
8H + 7O -> 4H2O + 3O
Then the remaining oxygen will combine with the CO to form CO and CO 2.
5CO + 3O -> 2CO + 3CO2
Finally the remaining nitrogen forms in its natural state (N2).
4N -> 2N2
The balanced reaction equation is:
C(CH2ONO2)4 -> 2CO + 4H2O + 3CO2 + 2N2
14
(2) Determine the number of molecular volumes of gas per gram molecule. Since the molecular volume of one gas is
equal to the molecular volume of any other gas, and since all the products of the PETN reaction are gaseous, the resulting number of molecular volumes of gas (Nmol) is:
Nmol = 2 + 4 + 3 + 2 = 11 mol-volume/mol
(3) Determine the potential (capacity for doing work). If the total heat liberated by an explosive under constant volume
conditions (Qm) is converted to the equivalent work units, the result is the potential of that explosive.
The heat liberated at constant volume (Qmv) is equivalent to the liberated at constant pressure (Qmp) plus that heat
converted to work in expanding the surrounding medium. Hence, Qmv = Qmp + Work (converted).
a. Qmp = Qfi (products) - Qfk (reactants)
where: Qf = Heat of Formation
For the PETN reaction:
Qmp = 2(26.43) + 4(57.81) + 3(94.39) - (119.4) = 447.87 kcal/mol
(If the compound produced a metallic oxide, that heat of formation would be included in Q mp.
15
16