Академический Документы
Профессиональный Документы
Культура Документы
OBJECTIVE
2010-EE-071
MUHAMMADSUFYAN KHAN 2010-EE-123
FARHAN
2010-EE-107
EHTISHAM WAHEED
BLOCK DIAGRAM
BACKGROUND
GROUP MEMBERS
PID controlling
Virtual HMI
FULLY AUTOMATED
MULTIPLE INPUTS AND OUTPUT
ARRANGEMENTS
EXTENDED TEMPERATURE RANGES
IMMUNITY TO ELECTRICAL NOISE
INDUSTRIAL PURPOSE
INDUSTRIAL ENVIRONMENT
CONCLUSION
MECHANICAL
Several techniques can be implemented to
control the boiler in power plant. The
method that has to be used relies on varied
objectives like superior quality, increased
efficiency, high profit and other such points
depending upon the purpose of the
company that implies it. With the prime
objective of catering to these necessities
and the needs of the industrial sector,
significance has been given here to
automation.
GROUP MEMBERS
MUHAMMAD MUJTABA
ARSALAN KHURSHID
ARIF ALI
2010-EE-089
2010-EE-121
2010-EE-122
METHODOLOGY
GROUP MEMBERS
EHTISHAM WAHEED
2010-EE-071
MUHAMMADSUFYAN KHAN 2010-EE-123
FARHAN
2010-EE-107
METHODOLOGY
PLC (Delta DVP14SS211-R)
Solenoid Valve
Temperature
Sensor
ModBus Protocol
Temperature Sensor
A platinum resistance temperature detector
(RTD) Pt100 is a device with a typical
resistance of 100 at 0C (it is called
Pt100). It changes resistance value as its
temperature changes following a positive
slope
(resistance
increases
when
temperature is increasing).
Pressure Sensor
Pressure Sensor
FST800-211 is used as a pressure sensor.
The pressure sensor can measure 3-5 psi.
Solenoid Valve
A solenoid valve is an Electromechanically
operated valve. The valve is controlled by
an electric current through the solenoid.
The solenoid valve controls the water input
in boiler. The solenoid valve can be
controlled through the PC based HMI.
The valve is operated at 220v AC.
SYSTEM MODULE
Liquid Level Sensor
Temperature Gauge
Temperature Monitor
Pressure Gauge
Pressure Sensor
Safety Valve
Solenoid Valve
Heater
PID on PLC
OPC Client & Server
ModBus Protocol
LabView HMI
PLC HMI
National Instruments LABView 2011 is used
to construct the HMI. Also NIs OPC Server
is used to setup communication between
HMI and PLC. Inputs, outputs, special
registers and data registers are accessed
by using Tags specified in the OPC server.