Академический Документы
Профессиональный Документы
Культура Документы
Contents
Angular Measurement
Angular Tools
Types Of Tools
Sine Bar
Try square
Dial Gauge
Clinometers
2
Angular Measurement
Circles are divided into 360 equal parts,
each being a degree.
Each of these degrees can be evenly
divided into 60 equal parts. These parts
are called minutes.
These minutes can be evenly divided
into 60 equal parts. These parts are
called seconds.
3
Simple Protractor
Multi-Use Gauge
Combination Set
Universal bevel protractor
Protractor
Multi-Use Gauge
Pre-set positions for
45 and 90 degrees,
59 degree drill point
angle, and whole
degree increments.
Multi-Use Gauge
Multi-Use Gauge
Multi-Use Gage
10
11
Protractor Head
Whole
degree
increments
12
Protractor
Built-in
Spirit
Level
13
Protractor
Angular
Measure
with
Protractor
Head
14
Transfer-type
Protractors
15
Universal Bevel
Protractor
Precision angles to
within 5' (0.083)
It Consists of : Base
Vernier scale
Protractor dial
Sliding blade
Dial clamp nut
16
Vernier Protractor
Used to measure obtuse angle (90-180)
Acute-angle attachment fastened to
protractor to measure angles less than 90
Main scale divided into
two arcs of 180
Scale divided into 12
spaces on each side of 0
If zero on vernier scale
coincides with line on
main: reading in degrees
17
Reading a Vernier
Protractor
Note number of whole degrees between zero
on main scale and zero on vernier scale
Proceeding in same direction, note which
vernier line coincides with main scale line
Multiply number by 5' and addFourth
to
degrees on protractor dial
50
4 x 5'= 20'
Reading =
50 20'
18
Sine Bars
Used when accuracy of angle must be
checked to less than 5 minutes
Consists of steel bar with two cylinders
of equal diameter fastened near ends
Centers of cylinders exactly 90 to edge
Distance between centers usually 5 or 10
inches and 100 or 200 millimeters.
Sine Bar
20
Sine Bars
21
TRY SQUARE
A try square is a wood working or a metal working used
for marking and measuring a piece of wood.
The square refers to the tool's primary use of measuring
the accuracy of a right angle (90 degrees); to try a
surface is to check its straightness or correspondence
to an adjoining surface. A piece of wood that
is rectangular, flat, and has all edges (faces, sides, and
ends) 90 degrees is called four square.
22
23
Dial Gauge
The dial gauge also known as the indicating
gauge and used for checking concentricity of
rods, holes and flatness of surfaces to accuracy
of 0.01mm. These gauges are widely used on
lathe.
24
Clinometer
A clinometer is an instrument used for
measuring angle relative to the horizontal plane.
25
Type Of clinometer
Vernier Clinometer
Micrometer
Dial
Pendulum
Optical
26
THANKS
27