Академический Документы
Профессиональный Документы
Культура Документы
Parts List
• 55 gallon drum
• 2 – ½” floor flanges
• 2 – rubber gaskets
• 72” x 3/8” LP hose
• 3/8” FL x ¼” MPT Conn
• 3/8” FL x ¼” FPT CPLG
• ½” cap
• ½” x 3” double threaded pipe
• LP nipple fitting (for gas tank)
• ½” x ¼” reducer
• ½” x 12” double threaded pipe
• 4 – top lock ¼” – 20 Gr C Nuts
• 4 – ¼” SAE thru hard YZ washers
• 4 – ¼” – 20 x 1 yz bolts
Start with a full
size barrel
Then decide on
the size you
desire:
Small
Medium
Large
Cut a hole in the barrel using a ½” knock out
punch.
Drill the holes for the floor flange to attach to the
barrel.
Take your rubber gasket material and cut to the
size of the flange with all the holes punched out.
Take the floor
flange, gasket
and bolts and
place on the
outside of the
barrel.
Once the outer materials are in place, piece
together the inside pieces and tighten the nuts.
If desired after the flanges have been tightened,
you can prime and paint the barrel for appearance.
Decide what length pipe will be inside the barrel.
Once completed drill 3 holes evenly spaced on the
pipe 7/64 – 1/8 ” in size.
Place the cap on one end and screw the other into
the inner flange.
Take the 3” pipe and screw into the outer flange.
Take the ½” x ¼” reducer and place on the pipe,
then take the 3/8” FL x ¼” MPT fitting and screw
into the reducer.
Take the hose and screw onto the fitting. Take the
3/8” FL x ¼” FPT CPLG fitting and screw into the
hose then take the LP nipple fitting and screw in
into place.
Completed Project.
Large Barrel