Академический Документы
Профессиональный Документы
Культура Документы
secure office
GUIDED BY:
DEPARTMENT OF ELECTRONICS
AND COMMUNICATION
1
SUBMITTED BY:-
2
CONTENTS
Abstract
Introduction
Aim of the project
Project details
Block diagram
Explanation
Power supply
Microcontroller
Security Device
Relay and Motor driver
Buzzer
Switching circuit
Application
Advantage
Future scope
Future development or Limitation
References
3
ABSTRACT
4
introduction
As we all know in todays world we need
security so, our project is totally based on
the security applications.
This project is based on hardware
implementation So, here we have
considered microcontroller (AT89S51) and
interface the system with various security
peripherals.
Security peripherals like trace passing
based protection, Door Breaking based
architecture for correct user identification.
Additionally Smoke sensor has been
intriduced to detect any abnormal
hazardous situations.
5
Region for choosing the project:
Now a days we need security every
where and every time so the main aim
of this project is to design a office
security system based on GSM
technology.
It can detect the unauthorized person
and sends an alarm message to the
admin.
6
PROJECT DETAILS
Hardware requirements:
Microcontroller
GSM module
Step down transformer(220 volt)
LDR sensor
OPAMP(LM393)
PCB board(circuit design)
7
Component Requirements:
Microcontroller
Sensors
Comparators
Top View Simulator software
Programming in Sunrom Programmer
8
POWER SUPPLY
+5V +12V
SECURIT
Y SIGNAL
SENSOR CONDITIONER
SNAP
S
SMOK
E
SENSO
R MICROC
DTMF ONTROL MULTIPL
INPUT LER E
LOADS
MOBIL
CRYSTAL E
OSCILLA
TOR
GND 9
Hardware circuit
10
explanations
11
POWER SUPPLY
7805 1k
+5V
9-0-9Vac/1Amp
LED
- +
230VAC
7812 +12V
50Hz 2.2k
IN4007 * 4
1000uF/35V
LED
GND
12
HARDWARE CIRCUIT OF POWER
SUPPLY
13
MICROCONTROLLER(AT89S51
)
14
PIN CONFIGURATION
15
HARDWARE CIRCUTE OF
MOTHERBOARD
16
Block diagram of opamp circuit
17
Hardware circuit of opamp
18
B U Z Z E R D R I V E R
V C C
B U Z Z E R
1 .5 K
D A T A
I N P U T B C 5 4 7
19
SWITCHING CIRCUIT
20
HARDWARE CIRCUIT OF SWITCH
21
Hardware circuit of gsm module
22
Overview of project
23
ADVANTAGE
Low cost.
Easier Troubleshooting.
Reliable.
Robust.
24
APPLICATION
Industrial security
Bank security
Home security
Locker security
25
Future development
Range
Cost
Interfacing
26
FUTURE SCOPE
This same project can be implemented in
PLC based system.
High end sensor system may be replaced
with the existing for more reliable security
purpose.
We can add the module of voice alarm
system instead of buzzer to indicate any
disturbance with the security.
Through the voice alarm system user can
also grant permission to other person
whether that person will come inside or not.
27
REFERENCEs
A.Mazidi, J.G.Mazidi and R.D.McKinlay, The 8051 Microcontroller and
Embedded Systems.
National Semiconductor Corporation, ADC 0808, journal published,
America, October 1999.
R.P.Jain, Modern Digital Electronics, TMH Publication 2003
Atmel Corporation, AT 89S51, literature journal published, CA.
Op-Amp and Linear integrated Circuits by Ramakant A. Gayakwad.
Electronic device and Circuit Theory by Robert L. Boylestad and Louis
Nashelsky.
Y. Zhao and Z. Ye, A Low Cost GSM/GPRS Based Wireless Home
Security System, IEEE Transactions on Consumer Electronics, vol. 54,
no. 2, pp. 567-572, 2008.
GSM Based Home Automation with Security (Using Microcontroller) Dr.
Shaik Meeravali 1, P. Sai Prasad 2 International Journal of Engineering
Research &Technology (IJERT) Vol. 2 Issue 9, September -2013ISSN:
2278-0181.
28
K YO U
T H A N
29