Академический Документы
Профессиональный Документы
Культура Документы
Module 10
1. Introduction
The welding inspector can employ one or more of the following methods
1. Introduction
examination method:
2) Acceptance standards.
3) Economics
COMIMSA Module 10
2. Visual Examination
the early discovery of most defects that, if left undetected, would later be
2. Visual Examination
2. Visual Examination
COMIMSA Module 10
2. Visual Examination
COMIMSA Module 10
2. Visual Examination
COMIMSA Module 10
2. Visual Examination
COMIMSA Module 10
applicable specification.
COMIMSA Module 10
Advantages
Limitations
Prods
Yokes
Coils
Advantages
Limitations
deposited weld metal differ appreciably from those of the base metal.
The use of a variable light intensity viewer is helpful when viewing and
analyzing radiographs.
Limitations
As the joint becomes more complex increase the cost and decrease
the amount of information.
Radiation Hazard
COMIMSA Module 10
Uses
reference standard.
COMIMSA Module 10
In scanning welds, this is achieved by angle beams into the work, though
a Lucite wedge and into the work through water, oil, or similar coupling
material
Advantages
Limitations
Materials with large grain size tend to scatter and disperse the sound
beam.
fields.
ET is employed on magnetic or
nonmagnetic materials.
If a variation in flux is
associated with discontinuities
in the material, the
discontinuities are detected.
COMIMSA Module 10
Advantages
Advantages
ET can detect many material characteristics:
Electrical conductivity
Magnetic permeability
Alloy content
Heat Treatment
Limitations
7. NDE Symbols
COMIMSA Module 10
7. NDE Symbols
COMIMSA Module 10
7. NDE Symbols