Академический Документы
Профессиональный Документы
Культура Документы
ISSUE 1.0
2 Internal Use
References
《31041768-WCDMA NodeB
Software Installation(V1.50)》
3 Internal Use
Chapter 1 Overview
4 Internal Use
Overview
5 Internal Use
Chapter 1 Overview
6 Internal Use
Installation Environment
Hardware requirements
Basic Recommended
Item configuration configuration
CPU PIII 600Hz P4 1.2GHz
RAM 128M 512M
Hard disk 10G 40G
Software requirements :
7 Internal Use
Installing MSDE2000 Release A
8 Internal Use
Installing MSDE2000 Release A
9 Internal Use
Installing XCT
10 Internal Use
Installing XCT
In the window, read the license agreement. Select “I accept these terms”,
and click <Next> to continue
11 Internal Use
Installing XCT
12 Internal Use
Installing XCT
In the window, select the components to install, and then click <Next > to
continue.
In the window, check the installation information
13 Internal Use
Installing XCT
After the system finishes copying files, click <Finish > in the window as
shown;
Restart the PC to finish installation.
14 Internal Use
Chapter 1 Overview
15 Internal Use
Installation Environment
16 Internal Use
Installation of LMT Software
17 Internal Use
Chapter 1 Overview
18 Internal Use
Overview
19 Internal Use
Preparation
iManager M2000
LMT6
NodeB
LMT1
Internet/DDN
IPoA Modem
NodeB PSTN
Modem LMT4
LMT3
20 Internal Use
Installation Procedure
Start
N Upgrade NodeB
Right version?
software
Y
Record the local IP
address
Download data
configuration file
Configured with N
RRUs?
Reset NodeB
N
Run stablly? Handl faults
Y
Sychronize NodeB
software version
End
21 Internal Use
Querying NodeB Software Version
22 Internal Use
Record Local IP Address
23 Internal Use
Downloading Data Configuration File
24 Internal Use
Installing RRU Software
25 Internal Use
Installing RRU Software
26 Internal Use
Installing RRU Software
27 Internal Use
Resetting NodeB
To make the data configuration file effect, reset the NodeB using
the MML command RST SYS.
The local IP address in the data configuration file replaces the
default IP address of the NMPT Ethernet port
28 Internal Use
Synchronizing NodeB Software Version
There are two paths in the NMPT file partition, that is the active
path and the standby path.
The path saving the running NodeB software is called the active
path, while that saving the standby NodeB software is called the
standby path. Users can use MML command “ACT SOFTWARE” to
interchange these two paths.
After installing the software at NodeB side and running the software
for a period (at least 72 hours) to verify its reliability and stability,
then synchronize the software in the active path with that in the
standby path in the file partition of the NMPT. (SYN SOFTWARE)
29 Internal Use
30 Internal Use