Академический Документы
Профессиональный Документы
Культура Документы
STRIPPER
DIE
Stripper
• The main function of the stripper is to strip the stock material off
the punches after each stroke.
• The stripper may act as a guide for the punches.
• It also may hold the strip flat while the strip is being worked on.
STRIPPER
STRIPPER
DIE
TYPE OF STRIPPERS
• Strippers can be classified into two groups.
• Fixed strippers.
• Traveling strippers.
STRIPPER
FIXED STRIPPER
DIE
Fixed strippers
• Fixed strippers are easier and economical to manufacture.
• Fixed stripper is positive in performance.
• It can exert strong stripping force.
BOX / FIXED STRIPPER
BOX STRIPPER
BOXSTRIPPER
Box stripper
• Box stripper is a type of fixed stripper.
• The stripper is clamped and located
directly on the die block.
• In guide plate tools, the alignment of the
punch and die is ensured by guiding the
punch in the stripper.
A = STRIP WITDH + 0.5 mm • In pillar guided tools, fragile punches are
guided in the stripper to prevent breakage.
BOX / FIXED STRIPPER
Box stripper.
Box stripper.
• It depends on the type of the stop used. (when a fixed pin stop
is used the clearance should be more, because the strip has to
be lifted over the stop for feeding).
• The back edge of the charnel may serve as a back gauge to
correctly position the strip.
TRAVELLING STRIPPER
Travelling strippers
• Under the following conditions a fixed stripper may be
impractical.
• When it is necessary to clamp the strip in addition to its
stripping function.
TRAVELLING STRIPPER
DISTANCE BUSH
LIMIT BOLT ARRANGEMENT
ARRANGEMENT
• The design of the limit bolts should allow for the adjustment of
the stripper suspension.
• When socket head screws are used, the stripper adjustment is
attained by reducing the thickness of the compensator washer.
STRIPPING FORCE
Stripping force
• Stripping force for most of the operations ranges from
10 to 20% of the cutting force.
• If the tool has more than one punch the stripping for that tool
is the sum total of the stripping forces required for each punch.
• Stripping for blanking and piercing
STRIPPER
Stripping force
• The following factors affect stripping force:
• Stock material.
• Materials which have a high friction value and materials which
tend to cling are more difficult to strip.
eg : Silicon steel, Stainless steel etc.
• Surface condition of side walls.
• A punch which has a smooth finish on its side walls strip
easily.
STRIPPER WITH SPRINGS
STRIPPER WITH SPRINGS
STRIPPER WITH SPRINGS
STRIPPER WITH SPRINGS