Академический Документы
Профессиональный Документы
Культура Документы
HELIUM/CDA
BOMBING TEST
CHAMBER
a project proposal by:
Jhon Loyd I. Tenorio
BS ECE 4-1
INTRODUCTION
▹The bombing test is a special leak
test for small and previously
hermetically sealed parts which
contains internal devices. 2
MODULES
EE
DEPT.
THE PROBLEM
▹ Helium/CDA bombing test
chamber cannot be placed
inside the clean room
because these gases can 8
produce electrostatic
charges.
▹ Sensitive test pieces may be
contaminated by any
harmful factors (such as dirt)
outside the clean room.
OBJECTIVES
TO MINIMIZE TO AVOID
the wasted time any potential
and motion of the factors that can 9
The
Cabine Monito
CDA/Helium
t will r for
bombing test 1
be any 0
chamber will be
placed effects
placed inside a
inside that
Cabinet with
the may
Exhaust Fan
Clean occur
Room
PROJECT DESIGN
• CDA/Helium bombing
test chamber will be
placed inside the cabinet
as shown in the figure at
the right. 1
1
• The cabinet contains an
exhaust fan that will
consume CDA/Helium
gases after the operator
releases the pressure
inside the bombing test Exhaust Fan
chamber.
PROJECT DESIGN
• The cabinet contains two normally
close switches S1 and S2 connected
in series. Closing the cabinet results in S2
an open circuit condition.
• Opening the two glass panels of the
cabinet untriggers S1 and S2 therefore 1
2
turning the exhaust fan on. S1
MATERIALS NEEDED
• Stainless Steel
• Glass Panels
• Exhaust Fan S2
• Normally closed switches
• Wires (capable of conducting 220VAC)
1
3
S1
KEY PERSONNEL
▹Equipment Engineering Department is
capable of implementing this project since it
only requires simple type of materials.
▹Operators can use these equipments at ease.
1
4
THANK YOU!
15