Академический Документы
Профессиональный Документы
Культура Документы
What is LOGIQ-B?
• Processing Subsystem
• Output Subsystem
Tool Input / Power Subsystem
• WSP7 • MATSUSADA
• ELGAR-1 • XMP
• ELGAR-2 • PTC
• CALIFORNIA (AC3) • CHIP
• XANTREX (DCPS)
LOGIQ-B Subsystem
The LOGIQ is a digital logging system and such can be
separated into three functional subsystems
• Output Subsystem
LOGIQ-B Subsystem
The LOGIQ is a digital logging system and such can be
separated into three functional subsystems
• Processing Subsystem
• Direct themode
In SAFE wireline to PTC in the LOG position
NO wireline In SAFE mode each conductor
conductors pass through is individually grounded through
• Configure the
WSP7 to PTC
wireline for internal signal and power processing
independent sets of two 10kΩ
in the
casing collar locator (CCL), SAFE, and ARM positions
resistors in parallel
• In the LOG position, WSP7 is transparent to the power and signal
• WSP7 can apply shooting power to line 7 ONLY
• WSP7 can record shooting current and voltage in perforating
ELGAR
• Provide AC power to the tools 2nd : push output ‘on’
1250VA : push program button
1 st button to attach power
Standby sw
Rear Panel SW1 assignments 4th : turn the knob to apply power
1 2 3 4 5 6 7 8
To apply power OFF 2nd : Change SW1-7
manually ON to ‘Off’ position
• Provides tool power and processes data for Cased Hole tools
• Controlled by Warrior software
CHIP Cards
TELA TELA : processes telemetry signal for MUX tools
PRELAYS Pre Relays : connects power supply and signal to wireline
AFP Apply Free Point : used only for Freepoint service
SPARE
SPARE
PSXD Power Supply Aux : controls all relays & power supply,
ANASW Analog Switch voltage
and measures : routes&thecurrent
signals to different places
CCL CCL : conditions CCL signal
CBL01 CBL01 : processes CBL and MUX signals
CBL02 CBL02 : validates sync signal of CBL and MUX tool
AUDIO AUDIO : used for noise service
MTT
USB44 USB44 : communicates with computer and digitizes
DSPAUX DSPAUX : digitizes
some analog signalssignals
(depth,from CBL1,2
tension, free&point
AUDIOetc.)
SDSDSP SDSDSP
board, and: works
controltogether withinDSPAUX
DAC level CBL2 & FP board
IP Settings for RMPC
IP : 10.10.1.1
Used to communicate with
the devices in INSITE network
(e.g FE PTC : 10.10.1.12)
IP : 10.0.0.1
Used to communicate with
the devices in CLASS network
(Now used to communicate with
Print Server only : 10.0.0.121)
Thank you
Any Questions?