Академический Документы
Профессиональный Документы
Культура Документы
OUTLINE
• TOPIC 1 :Introduction to Electronic Circuit Simulation and Software
Packages
• TOPIC 2 : Simulation of Analogue Circuits
• TOPIC 3 : Simulation of Digital Logic Circuits
• TOPIC 4 : Printed Circuit Board (PCB) Layout Design
COURSE LEARNING OUTCOME :
CLO2 : construct the simulation and the PCB layout for digital and
analogue circuits using a schematic capture software
( P4 , PLO 5)
TOPIC 1
INTRODUCTION TO
ELECTRONIC
CIRCUIT
SIMULATION
AND
SOFTWARE PACKAGES
WHAT IS CIRCUIT SIMULATION?
PCB DESIGN
Component and 3D
Simulation
9
10
PROCEDURE USING PROTEUS:
PART A: Electronic Simulation Package
Edit Components
To edit component, double click on the component and the ‘Edit
Component’ dialog box as below will appear. Then, edit and click
‘OK’.
25
a) Wire the Connection between Components
1. In order to wire the connection between components, for example; hover
the mouse over the output of LM324 such that in turns green and the left
click to start wire placement.
2. Move the mouse along to the resistor and the left click the mouse once to
place an ‘anchor’.
Use ‘L’ to search in device Libraries.
14. Toolbars and pull down menu.
NEW
PROJECT
start a new
project.
ELECTRICAL
RULES CHECK
R1 C1
A
10k
1nF
D1
V1 DIODE
VSINE
Q1
NPN
B
R2
10k