Академический Документы
Профессиональный Документы
Культура Документы
CONTENTS:
Flow Charts
Results Conclusion Future scope
AIM
INTRODUCTION
Radar is an Electromagnetic system which uses radio waves to detect the existence of an object and to find its position.
By means of radar the presence of moving or stationary objects such as aircrafts, ships and land masses can be detected.
The word RADAR is coined from the initial letters of the phrase: Radar Detection and Ranging.
BLOCK DIAGRAM
HARDWARE DETAILS
The following hardware has been used to build the project :
MICROCONTROLLER AT89S52 RS232 STEPPER MOTOR DRIVER CIRCUIT FOR STEPPER MOTOR OPTICAL TRANSDUCER SLOT SENSOR
MICROCONTROLLER
Here we use AT89S52 microcontroller which is manufactured by ATMEL. The AT89S52 is a low-power, high-performance CMOS 8-bit microcomputer with 8K bytes in-system programmable Flash memory A special feature called WATCH DOG TIMER is included which is intended as a recovery method for situations where the CPU may be subjected to software upsets.
RS232
The serial port on our PC is a full-duplex device i.e. it can send and receive data at the same time using separate lines for transmitting and receiving data. RS-232 stands for Recommend Standard number 232 and C is the latest revision of the standard. The MAX232 I.C converts input TTL level into RS-232C standard level and connects to PC through 9-pin D-type connector.
The diagram for the handshaking between the system and the connecter is as shown below:
We cannot simply connect our system to the terminal without providing proper hand shaking signal.
STEPPER MOTORS
A stepper motor is an electro-mechanical device, which converts electrical pulses into discrete mechanical movements.
For driving of motor coils, we have used IRF540 MOSFET, which are
OPTICAL TRANSDUCER
Optical transducer consists of LED and Photo Diode where LED acts as a transmitter while Photo Diode acts as a receiver.
SLOT SENSOR
It consists of IR light emitting diode (LED1) and phototransistors (Q1). It is used to detect the position of the target.
When the diode is in OFF state, no light falls on the base of phototransistor. Therefore, it acts as open circuit. It implies that the antenna is in the reference position , and when the diode is in ON the phototransistor is short circuited this implies that the antenna is away from its respective reference position.
start Initialize serial port with 9600 Baud rate. Bring antenna to reference position with the help of Slot Sensor Increment the step counter, if step count is greater than or equal to 400, reset step count to 0 & complement the antenna direction If the direction is clockwise move motor clockwise 1 step else move motor anti clockwise 1 step
Scan IR Sensor and send the status along with the direction through the serial port.
Continue to step3.
PROJECT HARDWARE
RESULT
The following output is obtained on the PC , we can observe the angle and the time at which the obstacle is detected.
APPLICATIONS
Radars are used to determine the range, altitude, direction, or speed of both moving and fixed objects.
Meteorologists use radar to monitor precipitation. It is used for weather forecasting and to watch for severe weather such as thunderstorms ,tornadoes and winter storms
Aeroplanes can land in fog at airports equipped with radar-assisted groundcontrolled approach (GCA) systems, in which the plane's flight is observed on radar screens while operators radio landing directions to the pilot.
Geologists use specialized groundpenetrating radars to map the composition of the Earth's crust.
ADVANTAGES
Superior penetration capability through any type of weather condition, and can be used in the day or night time. Radars does not require a medium like Sonar (that uses water) so can be used in space and air. Radar can be long range and the wave propagate at the speed of light. It is less susceptible to weather conditions compared with Lasers and can be used at night unlike passive cameras. It does not require target cooperation to emit any signals or emission.
DISADVANTAGES
CONCLUSION
This project is designed for implementing the RADAR SIMULATION WITH OPTICAL SENSOR using a PC to detect an obstacle. In real time we have various applications of this project. This is a Reference Model of the RADAR which is used in real time applications.
THE FUTURE
We can add other features like, camera feedback to see the targets, radar sensor to detect intruders.
The military uses it to detect the enemy and to guide weapons thus considerably decreasing human loss.
Meteorologists use radar to track storms, hurricanes and tornadoes.
The Sea-Based X-Band (SBX) Radar system, it is a semi-submersible twinhulled oil-drilling platform. SBX can patrol the worlds oceans looking for ballistic missile launches.
The radar system is for quick setup and deployment for Marines and other rapidly deployable forces that need battlefield surveillance and air traffic control.
QUERIES