Вы находитесь на странице: 1из 3

N 2 2.01.

07-85*
" "
( 29 2003 . N 45)

Change N in 2 SNIP - Construction norms and regulations 2.01.07-85 * "loads and action" (adopted and introduced into the action by
the resolution of Gosstroy - State Committee for Construction RF of 29 May, 2003, N 45)
1. 1.3. ) :

Point 1.3. A) to present in the following editorial staff:


") - ..2.2., 3.4., 3.7., 3.11., 4.8., 6.11., 7.3. 8.7.;"

with the calculation for the strength and the stability - in accordance with p.p.2.2., 3.4., 3.7., 3.11., 4.8., 6.11., 7.3. and 8.7.
2. 1.7:
"" :

subparagraph "k" to present in the following editorial staff:


") ,
0,5";

j) load due to snows with the lowered computed value, determined by the multiplication of total computed value for coefficient of 0,5
:

to supplement point with the note of the following content:


". 5 ( 5 2.01.07-85*)
."

"note. In the regions with the mean temperature of January minus of shchS and above (on the map of appendix 5 to SNIP Construction norms and regulations 2.01.07-85 *) load due to snows with the lowered computed value are not established."
3. ) 1.8. :

3. subparagraph d) point 1.8. to present in the following editorial staff:


") ".

"d) load due to snows with the total computed value".


4. 5.1. :

4. point 5.1. to present in the following editorial staff:

"5.1. :

"5.1. The total computed value of load due to snow on the horizontal projection of coating should be determined from the formula:
S = S x ,
g
S

1 2

,

.5.2.

where S - the computed value of the weight of snow cover for 1 m2 g of the horizontal earth's surface, taken in accordance with
p.shch.2.
-
,
..5.3. - 5.6."

mu - conversion factor from the weight of snow cover of the earth to the load due to snow on the coating, taken in accordance with
p.p.shch.e. - 5.6."
5. 5.2. :

5. point 5.2. to present in the following editorial staff:


"5.2. S_g 1 "
4.

"5.2. The computed value of the weight of snow cover S_.g on 1 m "the horizontal earth's surface should be taken depending on the
snow region of the Russian Federation according to the data of table 4.
4

| |
|
|
|
|
|
|
|
|
| ( 1 |
I
| II
| III | IV
|
V
| VI
| VII | VIII |
|
5)
|
|
|
|
|
|
|
|
|
||||||||||
|
S_g,
| 0,8 | 1,2 | 1,8 | 2,4 | 3,2 | 4,0 | 4,8 | 5,6 |
|
(/2)
| (80) | (120) | (180) | (240) | (320) | (400) | (480) | (560) |

: Note:
, 1 5,
1500 , , 4
.
S_g 25 ,
(
) 20 ."

In the mountain and insufficiently studied regions, designated on the map of 1 required appendix 5, in the points with a height it is
above sea level more than 1500 m, in the places with the complex relief, and also with an essential difference in local data from those
given in Table 4 the computed values of the weight of snow cover should be established on the basis of data of the Russian Federal
Service on Hydrometeorology and Environmental Control. In this case as computed value of S_.g should be assumed exceeded on the
average once a 25 years the yearly maximum of the weight of snow cover, determined on the basis of the data of route snow
surveying about the water supplies in the protected from the direct action of wind sections (in the scaffolding under the crowns of trees
or on the forest clearings) during the period not less than 20 years."
6. 5.7. :
"5.7. 0,7."

"5.7. The normative value of load due to snow is determined by the multiplication of computed value for coefficient of 0,7."
7. 1 " " 5 1 "
".

7. map 1 the "division into districts of the territory OF THE USSR for the weight of snow cover" of appendix 5 to replace by map 1 the
"division into districts of the territory of the Russian Federation in terms of the computed value of the weight of snow cover of the
earth".
. " 1* "
"

See graphic object "map 1 *" the division into districts of the territory of the Russian Federation in terms of the computed value of the
weight of snow cover of the earth "

Вам также может понравиться