Академический Документы
Профессиональный Документы
Культура Документы
Lecture quiz
Louie Navalta
https://docs.google.com/forms/d/e/1FAIpQLSdBG4u_8gOZsJ7qspy--1jxqaBuTIFBJA55iQmkXe54IeyRXw/viewscore?viewscore=AE0zAgCSWQdNN… 1/7
2/11/22, 3:00 PM Week 2. Lecture quiz
The slag was equilibrium with metallic iron, so it did not contain Fe3+ at 1400 C.
Шлак был в равновесии с металлическим железом, поэтому не содержал Fe3+
при 1400 С.
Iron chips were consumed by the crucible. So, only CaO, SiO2 and Fe2O3 remained in
slag at 1400 C. Стружки железа был поглощены тиглем. Поэтому, только CaO,
The slag was fully liquid at 1400 degrees C. Шлак был полность жидким при
1400 градусах С.
It is not possible to say, whether the slag was fully liquid at 1400 degrees C, because
invariant temperatures are labelled, but isotherms are not labelled. Невозможно
сказать, будет ли шлак полностью жидким при 1400 градусах С, так как
инвариантные температуры показаны, а температуры для изотерм не
обозначены.
When the quenched slag was polished and mounted, large crystals of olivine (> 50
microns) could be observed in the optical microscope. Когда закалённый шлак
был отполирован и помещен в оптический микроскоп, можно было наблюдать
довольно большие кристаллы оливина (> 50 микрон)
The slag was in equilibrium with metallic iron, so the P(O2) in the system
represented the lowest possible P(O2) where liquid slag can exist (this bulk
composition and temperature). Шлак был в равновесии с металлическим
железом, поэтому P(O2) в системе являлась наиболее низким, при котором
жидкий шлак может существовать (для данного валового состава и
температуры).
Feedback
- The slag was equilibrium with metallic iron, so it did not contain Fe3+ at 1400 C. Шлак
был в равновесии с металлическим железом, поэтому не содержал Fe3+ при 1400
С.
Incorrect: The slag, was indeed in equilibrium with metallic iron, but it still contained small
amount of Fe3+, which can be measured. This can be observed on the Fe-O phase
diagram, where slag composition is always shifted from FeO towards higher concentration
of oxygen
- Iron chips were consumed by the crucible. So, only CaO, SiO2 and Fe2O3 remained in
slag at 1400 C. Стружки железа был поглощены тиглем. Поэтому, только CaO, SiO2 и
Fe2O3 остались в шлаке при 1400 С.
Incorrect: Iron chips will react with Fe2O3 and form “FeO” with small remaining
concentration of Fe3+
- The slag was fully liquid at 1400 degrees C. Шлак был полность жидким при 1400
градусах С.
Correct: All invariant temperatures around the circle are below 1225, so the slag will be
liquid above 1225.
https://docs.google.com/forms/d/e/1FAIpQLSdBG4u_8gOZsJ7qspy--1jxqaBuTIFBJA55iQmkXe54IeyRXw/viewscore?viewscore=AE0zAgCSWQdNN… 3/7
2/11/22, 3:00 PM Week 2. Lecture quiz
- It is not possible to say, whether the slag was fully liquid at 1400 degrees C, because
invariant temperatures are labelled, but isotherms are not labelled. Невозможно сказать,
будет ли шлак полностью жидким при 1400 градусах С, так как инвариантные
температуры показаны, а температуры для изотерм не обозначены.
Incorrect: All invariant temperatures around the circle are below 1225, so the slag will
liquid above 1225.
- When the quenched slag was polished and mounted, large crystals of olivine (> 50
microns) could be observed in the optical microscope. Когда закалённый шлак был
отполирован и помещен в оптический микроскоп, можно было наблюдать
довольно большие кристаллы оливина (> 50 микрон)
Incorrect: Large crystals only form if the were present at 1400 C in equilibrium with slag.
Since the slag was fully liquid, and quickly quenched, only very small solid crystals form.
Very likely, the slag will turn into amorphous glass.
Неверно: Большие кристаллы образуются только когда они находятся в равновесии
со шлаком при 1400 С. Так как шлак было полностью жидким, и закалён быстро,
только очень маленькие кристаллы успевают формироваться. Весьма вероятно,
такой шлак превратится в аморфное стекло.
- The slag was in equilibrium with metallic iron, so the P(O2) in the system represented the
lowest possible P(O2) where liquid slag can exist. Шлак был в равновесии с
металлическим железом, поэтому P(O2) в системе являлась наиболее низким, при
котором жидкий шлак может существовать.
Correct: If lower P(O2) would have been imposed, i.e. by the flow of hydrogen, all iron
oxide would be reduced into iron metal. The bulk composition of slag would move towards
CaO-SiO2 side and solidify.
Верно: Если создать более низкое P(O2), например потоком водорода, весь оксид
железа будет восстановлен в металл. Валовый состав шлака сместится в сторону
CaO-SiO2 и шлак застынет.
https://docs.google.com/forms/d/e/1FAIpQLSdBG4u_8gOZsJ7qspy--1jxqaBuTIFBJA55iQmkXe54IeyRXw/viewscore?viewscore=AE0zAgCSWQdNN… 4/7
2/11/22, 3:00 PM Week 2. Lecture quiz
In the case B, more solid metallic Cu(fcc) will be produced, but much less of 'Cu3As’.
В случае B, больше металлической меди Cu(fcc) будет получено, но меньше
'Cu3As’
https://docs.google.com/forms/d/e/1FAIpQLSdBG4u_8gOZsJ7qspy--1jxqaBuTIFBJA55iQmkXe54IeyRXw/viewscore?viewscore=AE0zAgCSWQdNN… 5/7
2/11/22, 3:00 PM Week 2. Lecture quiz
Cu3As .
Feedback
- In the case A, higher purity of liquid Pb can be achieved. В случае A, жидкий Pb будет
иметь чистоту выше, по сравнению с B.
Incorrect: The key is to realize that at 400 C, both A and B are located inside the triangle of
phases liquid Pb + Cu(fcc) + Cu3As. Cu(fcc) is solid metallic copper. While inside the
triangle, the COMPOSITIONS of these three phases DO NOT change, but the
PROPORTIONS of these phases DO CHANGE. The composition of Pb liquid, i.e. purity is
the same.
Неверно: В этом вопросе главное определить, что при 400 С оба соствава A и B
находятся внутри треугольника жидкий Pb + Cu(fcc) + Cu3As. В любой точке внутри
этого треугольника, СОСТАВЫ этих трёх фаз НЕ ИЗМЕНЯЮТСЯ, но ПРОПОРЦИИ этих
фаз МЕНЯЮТСЯ. Состав жидкого свинца, то есть его чистота постоянна.
- In the case B, less product of liquid Pb will be obtained. В случае B, меньше продукта
(жидкого свинца) будет получено.
Correct: As above, the proportions of phases change. In case of B, less Pb liquid and more
of Cu(fcc) and Cu3As.
Верно: Как объяснено ранее, пропорции фаз меняются. В случае B, меньше жидкого
свинка и больше твёрдой меди Cu(fcc).
- In the case B, more solid metallic Cu(fcc) will be produced, but much less of 'Cu3As’. В
случае B, больше металлической меди Cu(fcc) будет получено, но меньше 'Cu3As’.
Incorrect: As above, the mass of of both Cu(fcc) and Cu3As will higher in case B. To get
more Cu(fcc) and less Cu3As, the composition should shift towards the line connecting
case A and pure Cu.
Неверно: Как объяснено ранее, массы обоих фаз Cu(fcc) и Cu3As будут выше в
случае B. Чтобы получить больше Cu(fcc) и меньше Cu3As, состав должен
сдвигаться по линии, соединяющий точку A и медный угол.
Correct: We can get outside of liquid Pb + Cu(fcc) + Cu3As triangle into liquid Pb + Cu3As
region, where lower equilibrium concentrations of Cu can be achieved. Just follow the 400
C line on the bottom figure, the lowest concentration is observed at approximately 0.1
weight% As. This process is relatively low temperature (400 C), so some interesting kinetic
effects can be observed to the fact that reactions are slow.
https://docs.google.com/forms/d/e/1FAIpQLSdBG4u_8gOZsJ7qspy--1jxqaBuTIFBJA55iQmkXe54IeyRXw/viewscore?viewscore=AE0zAgCSWQdNN… 6/7
2/11/22, 3:00 PM Week 2. Lecture quiz
This content is neither created nor endorsed by Google. - Terms of Service - Privacy Policy
Forms
https://docs.google.com/forms/d/e/1FAIpQLSdBG4u_8gOZsJ7qspy--1jxqaBuTIFBJA55iQmkXe54IeyRXw/viewscore?viewscore=AE0zAgCSWQdNN… 7/7